1. DL manuals
  2. Garmin
  3. GPS
  4. Approach G5 - GPS-Enabled Golf Handheld
  5. Installation Manual

Garmin Approach G5 - GPS-Enabled Golf Handheld Installation Manual

Manual is about: standalone flight display or a fully integrated backup instrument for G3X systems

Summary of Approach G5 - GPS-Enabled Golf Handheld

  • Page 1

    190-01112-10 july 2016 revision 2 garmin g5 electronic flight instrument part 23 aml stc installation manual.

  • Page 2

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page a ©2016 garmin international or its subsidiaries all rights reserved except as expressly provided herein, no part of this manual may be reproduced, copied, transmitted, disseminated, downloaded or sto...

  • Page 3

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page b record of revisions revision revision date description 1 07-14-2016 initial release 2 07-21-16 revised to incorporate comments and changes driven by document reviews..

  • Page 4

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page i information subject to export control laws this document may contain information which is subject to the export administration regulations (“ear”) issued by the united states department of commerce ...

  • Page 5

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page ii warning this product, its packaging, and its components contain chemicals known to the state of california to cause cancer, birth defects, or reproductive harm. This notice is being provided in acc...

  • Page 6

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page iii note: use of polarized eyewear may cause the display to appear dim or blank. Note all screen shots used in this document are current at the time of publication. Screen shots are intended to provid...

  • Page 7

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page iv table of contents section ............................................................................................................................................ Page 1 general description ......

  • Page 8

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page v figures figure page figure 1-1 g5 electronic flight instrument ...................................................................................... 9 figure 1-2 g5 standby battery ...................

  • Page 9

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page vi table 3-3 supported garmin antennas ......................................................................................... 19 table 3-4 supported non-garmin antennas ...............................

  • Page 10

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 7 of 53 1 general description 1.1 introduction the g5 is an electronic instrument display capable of operating as a primary attitude indicator or rate-of- turn indicator. This stc will approve the ins...

  • Page 11

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 8 of 53 1.3 reference documents table 1-1: reference documents title document number faa advisory circular, acceptable methods, techniques, and practices – aircraft inspection and repair ac 43.13-1b f...

  • Page 12

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 9 of 53 1.6 system overview 1.6.1 equipment description the g5 electronic flight instrument is shown in figure 1-1. The g5 is an electronic instrument display operating as a standalone flight display....

  • Page 13

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 10 of 53 1.6.1.3 slip/skid the attitude indicator displays slip/skid information as indicated by the location of the ball at the lower center portion of the indicator. 1.6.1.4 gps the g5 requires gps ...

  • Page 14

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 11 of 53 figure 1-2 g5 standby battery 1.6.2 g5 interface summary the g5 electronic flight instrument in this stc installation uses 14vdc or 28 vdc power, ground, rs- 232 (2) , and coax (1) connection...

  • Page 15

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 12 of 53 1.6.3 outline and installation drawings figure 1-3 g5 outline drawing.

  • Page 16

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 13 of 53 figure 1-4 g5 installation drawing figure 1-5 g5 panel cutout measurements (not to scale).

  • Page 17

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 14 of 53 1.7 g5 pinout use the information in this section with other applicable sections/appendices to construct the wiring in accordance with faa approved standard practices. 1.7.1 j51 figure 1-6 j5...

  • Page 18

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 15 of 53 1.7.1.3 can bus can bus is not used or approved for use by this stc. 1.7.1.4 unit id the g5 detects its assigned unit type at startup by checking the unit id pin. Only one g5 may be installed...

  • Page 19

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 16 of 53 2 limitations 2.1 installation limitations it is the installer’s responsibility to ensure the installation will meet the requirements in this manual prior to modification the aircraft. As ins...

  • Page 20

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 17 of 53 3 installation overview 3.1 introduction the following section contains an overview of the steps required for the installation of the g5 electronic flight instrument. This section includes re...

  • Page 21

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 18 of 53 • tie wraps or lacing cord • ms25036 ring terminals (for grounding and circuit breaker connections) • shield terminators (as83519/1-x or equivalent) • silicon fusion tape, a-a-59163 (mil-i-46...

  • Page 22

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 19 of 53 3.4.1.1 garmin antennas table 3-3 lists garmin antennas supported by the g5. The ga35 and ga36 meet the requirements of tso/etso-c144. Table 3-3 supported garmin antennas model part number ga...

  • Page 23

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 20 of 53 3.4.5 placards and labels the new circuit breaker installed for the g5 unit must be labeled as noted in the interconnect drawing in section 4.6. 3.4.6 cable and wiring considerations wire sel...

  • Page 24

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 21 of 53 3.4.10 audio interference this stc installation does not interface to audio signals. Attention to harness installation and routing as specified in section 3.4.6 should be considered for audio...

  • Page 25

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 22 of 53 3.5.2.1 electrical load is reduced following modification if calculations show the overall load on the electrical system is reduced as shown in the following example, no further analysis is r...

  • Page 26

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 23 of 53 3.5.2.3 performing an electrical load analysis by measurement this section describes how to perform an electrical load analysis for a single alternator-single battery electrical system. These...

  • Page 27

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 24 of 53 figure 3-1 ammeter placement for current measurements 7. Ensure all circuit breakers are closed. 8. Apply external power to the aircraft. The voltage of the power source should be set to the ...

  • Page 28

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 25 of 53 14. Using the tabulation completed above, switch on all continuous electrical loads which are used for the normal cruise phase and record the current measured by the ammeter (measurement (c) ...

  • Page 29

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 26 of 53 figure 3-2 blank electrical load tabulation form, sheet 1 of 2.

  • Page 30

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 27 of 53 figure 3-3 blank electrical load tabulation form, sheet 2 of 2.

  • Page 31

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 28 of 53 figure 3-4 sample completed electrical load tabulation form, sheet 1 of 2.

  • Page 32

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 29 of 53 figure 3-5 sample completed electrical load tabulation form, sheet 2 of 2.

  • Page 33

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 30 of 53 4 installation procedures note it is critical that the g5 is installed perpendicular to the aircraft's longitudinal axis (display bezel parallel to the wing spar) and as close to level in the...

  • Page 34

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 31 of 53 figure 4-1 g5 mounting ring figure 4-2 maximum misalignment of the g5 in the lateral axis.

  • Page 35

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 32 of 53 figure 4-3 maximum misalignment of the g5 in the longitudinal axis figure 4-4 maximum misalignment of the g5 in the vertical axis.

  • Page 36

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 33 of 53 4.3 g5 installation the g5 is installed by inserting the alignment pin located at the top of the unit into the mating hole in the mounting ring, pushing the unit flush with the instrument pan...

  • Page 37

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 34 of 53 4.3.1 optional #6-32 captive mounting screw the captive 3/32” hex socket head screw can be used for panel thicknesses up to 0.150”. For installations with a panel thickness greater than 0.150...

  • Page 38

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 35 of 53 caution to avoid damaging the g5 pressure sensors, both the pitot and static ports must be connected to the test set. Caution verify sealant/tape is not present inside the plumbing upon assem...

  • Page 39

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 36 of 53 4.5.3 wiring harness assembly allow adequate space for installation of the wiring harness and connectors. Construct the wiring harness in accordance with the information contained in this and...

  • Page 40

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 37 of 53 12 split washer, #8 (0.045" compressed thickness), cad-plated steel, or split washer, #8 (0.045" compressed thickness), stainless ms35338-42, or ms35338-137 13 flat washer, cad-plated steel, ...

  • Page 41

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 38 of 53 preferred method alternate method figure 4-9 shield termination methods prepare all of the shielded wires using one of the shield termination methods shown in figure 4-9. Keep the shield drai...

  • Page 42

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 39 of 53 11. Wrap the wiring harness with silicone fusion tape (3) at the point where the strain relief clamp (7) and connector backshell (6) will contact the wiring harness. 12. Attach the strain rel...

  • Page 43

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 40 of 53 4.6 g5 interconnect drawings figure 4-10 g5 interconnect notes caution check wiring connections for errors before connecting the wiring harness to the lrus. Incorrect wiring could cause compo...

  • Page 44

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 41 of 53 4.6.1 g5 with rs-232 interface figure 4-11 g5 with rs-232 interface 4.6.2 g5 with external gps antenna figure 4-12 g5 with external gps antenna.

  • Page 45

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 42 of 53 5 system configuration and checkout procedures 5.1 overview this section contains instructions for configuration and checkout of the g5 electronic flight instrument. The steps which are not a...

  • Page 46

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 43 of 53 note as these procedures involve engine run-up and moving the aircraft, it is recommended that the installer read this entire section before beginning the checkout procedure. Note all test eq...

  • Page 47

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 44 of 53 5.3.5 software loading procedure g5 software loading can be performed in either normal or configuration mode. 1. Power on the g5, then insert a properly formatted microsd™ card into the micro...

  • Page 48

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 45 of 53 5.3.6.2 g5 configuration configure the g5 as shown in table 5-1. See section 5.4.1 for information about recording the configuration settings to keep in the aircraft records for future refere...

  • Page 49

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 46 of 53 config page config option configuration setting navigation note: this configuration page is only present when rs-232 input format is configured for mapmx navigation data disabled units altitu...

  • Page 50

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 47 of 53 5.3.7 g5 post-installation calibration procedures after mechanical and electrical installation of the g5 has been completed, prior to operation, a set of post-installation calibration procedu...

  • Page 51

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 48 of 53 5.3.7.1 calibration procedure a: pitch/roll offset compensation by aircraft leveling note this procedure requires orienting the aircraft to normal flight attitude. This can be done by using j...

  • Page 52

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 49 of 53 f. G5 connector not firmly attached to unit. G. Cabling leading to the g5 not firmly secured to a supporting structure. H. An engine/propeller combination that is significantly out of balance...

  • Page 53

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 50 of 53 5.3.8 pitot static system leak check perform a pitot static system leak check in accordance with the aircraft manufacturer’s approved data. Caution to avoid damaging the g5 pressure sensors, ...

  • Page 54

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 51 of 53 5.3.11 electromagnetic compatibility (emc) check an emc check must be conducted once the g5 is installed and all interfaces to external equipment are verified to be correctly working. The emc...

  • Page 55

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 52 of 53 victim g5 magnetic compa ss clock oat indicato r power plant instr uments a utopilot / sas navigation radio(s) communication radio(s) engine relight fuel valve pitot heat pulse light gene rat...

  • Page 56

    Garmin g5 electronic flight instrument part 23 aml stc installation manual 190-01112-10 rev. 2 page 53 of 53 5.4 documentation checks 5.4.1 instructions for continued airworthiness (ica) ensure the appropriate aircraft information is recorded in garmin g5 electronic flight instrument part 23 aml stc...