1. DL manuals
  2. Garmin
  3. GPS
  4. Approach G5 - GPS-Enabled Golf Handheld
  5. Maintenance manual

Garmin Approach G5 - GPS-Enabled Golf Handheld Maintenance manual

Manual is about: standalone flight display or a fully integrated backup instrument for G3X systems

Summary of Approach G5 - GPS-Enabled Golf Handheld

  • Page 1

    190-01112-11 july 2016 revision 1 garmin g5 electronic flight instrument part 23 aml stc maintenance manual including instructions for continued airworthiness.

  • Page 2

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page a ©2016 garmin international or its subsidiaries all rights reserved except as expressly provided herein, no part of this manual may be reproduced, copied, transmitted, disseminated, downloaded or stor...

  • Page 3

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page b record of revisions revision revision date description 1 7/22/16 initial release.

  • Page 4

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page i information subject to export control laws this document may contain information which is subject to the export administration regulations (“ear”) issued by the united states department of commerce (...

  • Page 5

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page ii battery warnings: if these guidelines are not followed, the lithium-ion battery may experience a shortened life span or may present a risk of damage to the device, fire, chemical burn, electrolyte l...

  • Page 6

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page iii table of contents section page 1 introduction ..................................................................................................................................... 1 1.1 introductio...

  • Page 7

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page iv figures figure page figure 2-1 g5 electronic flight instrument ...................................................................................... 2 figure 2-2 g5 battery ...........................

  • Page 8

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 1 of 18 1 introduction 1.1 introduction this document provides instructions for continued airworthiness (ica) for the garmin g5 electronic flight instrument as installed in part 23 aircraft under stc s...

  • Page 9

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 2 of 18 1.5 revision and distribution this document is required for maintaining the continued airworthiness of the aircraft. When this document is revised, every page will be revised to indicate curren...

  • Page 10

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 3 of 18 shows the current turn rate. A standard-rate turn is shown on the indicator by the trend vector stopping at the standard turn rate tick mark. The g5 displays slip/skid information as indicated ...

  • Page 12

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 5 of 18 4.4 battery capacity check 1. Without power applied to the aircraft, turn on the g5 by pressing the power button in the lower left corner of the unit. 2. Note the remaining battery capacity (%)...

  • Page 13

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 6 of 18 5.2 g5 attitude if the attitude is failed and shows a red-x condition, follow the troubleshooting steps in the previous section. If this does not resolve the issue, gather answers to the follow...

  • Page 14

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 7 of 18 5.6 outline and installation drawings figure 5-1 g5 outline drawing (side view) figure 5-2 g5 outline drawing (back view).

  • Page 15

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 8 of 18 figure 5-3 g5 exploded view 5.7 g5 interconnect drawings figure 5-4 j51 on the g5.

  • Page 16

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 9 of 18 figure 5-5 g5 with rs-232 interface figure 5-6 g5 with external gps antenna.

  • Page 17

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 10 of 18 6 equipment removal & installation this section describes how to remove and install the equipment associated with this stc. 6.1 g5 unit caution: when removing and/or installing the g5, always ...

  • Page 18

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 11 of 18 3. Reconnect the pitot and static lines to the g5 unit. The ports are labeled on the unit using the abbreviations “p” and “s” respectively. 4. Insert the alignment pin located at the top of th...

  • Page 19

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 12 of 18 6.3 g5 mounting ring replacement removal 1. Loosen the g5 unit per section 6.1. Do not remove the pitot and static lines or the electrical and gps coaxial cable connectors from the g5 unit if ...

  • Page 20

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 13 of 18 7 equipment configuration & testing this section contains instructions for configuration and checkout of the g5 electronic flight instrument after reinstallation or replacement. The steps whic...

  • Page 21

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 14 of 18 7.3.2 software loading procedure 1. Power on the g5, then insert the software loader card created in section 7.3.1 into the microsd™ card slot. 2. If the version of software on the card is new...

  • Page 22

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 15 of 18 table 7-1: g5 configuration settings date: aircraft make/model: aircraft reg #/serial #: g5 part #: g5 serial #: g5 software version: configuration page configuration option configuration sett...

  • Page 23

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 16 of 18 date: aircraft make/model: aircraft reg #/serial #: g5 part #: g5 serial #: g5 software version: configuration page configuration option configuration setting units altitude feet (ft) distance...

  • Page 24

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 17 of 18 7.5 g5 calibration procedures table 7-2 describes the calibration procedures to be performed for the g5 unit after maintenance is performed. Table 7-2: calibration procedure summary calibratio...

  • Page 25

    Garmin g5 electronic flight instrument part 23 aml stc maintenance manual 190-01112-11 rev. 1 page 18 of 18 caution to avoid damaging the g5 pressure sensors, both the pitot and static ports must be connected to the test set. 1. Select the air data configuration page. 2. Select calibrate static pres...