Instruction manual apex apex the by holland the only grill not to flare up! ©the holland grill co., inc. V2012a pn ss5-man-bo ansi z21.58-2007/csa 1.6-2007 body only bh421-ss5lpb lp gas barbecue industry association member this grill is equipped with a #57 orifice for lp gas from the factory. Do not...
Warning ! Do not let children operate or play near grill. Keep grill area clear and free from materials that burn do not block air vents in grill check burner flames regularly use grill in well ventilated space. Never use grill in enclosed space such as garage, porch or covered patio. Use grill at l...
Simply close the lid and cook by time. It’s guaranteed not to flare-up. Cutaway side view of your patented holland grill no flare-up system stainless steel cooking grid stainless steel grid cleans easily and prevents small foods from falling through. Aluminum drip pan catches all the drippings and p...
A-1 holland apex body only grill owners manual safety information please read carefully. Warning: never operate this grill on natural gas unless it has been properly equipped for use with natural gas. Improper use may result in an explosion and/or fire and serious accident or injury. Contact your lo...
A-2 natural sas supply valve or the lp gas cylinder is the primary valve and must be closed when the grill is not in use. The on position is when the handle is in line with the burner (see figure 6 for details. See lighting instructions for more information.) the burner valve controls the heat allow...
#8-32 x 1/2” round head phillips #10-24 hex nut 1/4 - 20 x 5/8” hex head bolt 1/4” lock washer #10 lock washer note: use one lock washer per bolt, either under the hex nut or under the bolt head if a hex nut is not used. #10-24x1/2” carriage bolt #8 lock washer 1/4 - 20 x 1” round head phillips #10-...
A-4 step 3. Refer to figure 2. Select the following items: 1. Grill bottom assembly 2. Lid stops 3. Hinges select one of the lid stops. Insert the end of the lid stop with the slot in it into the slot in the body bottom end panel. Insert a t-nut through slot in lid stop. Insert 10-24 phillips screw ...
A-5 install control knobs. Push black igniter knob firmly until it snaps into place, once installed correctly, it should not come off easily. Secure silver gas control knob to post by tightening set screw. Use small allen wrench provided. Step 7. Refer to figure 5. Select the following items: 1. Gri...
A-6 step 9. Refer to figure 6b. Select the following items: 1. Drip pan 4. Cooking grid 2. Drain pipe 5. Drip bucket 3. Drain valve install the drain pipe into the female threaded coupling in the right end of the drip pan. Tighten with pliers or pipe wrench. Carefully set the drip pan into grill bot...
A-7 with holland's body-only apex grill, trim kit, double doors and searmate you have all you need to get started on building your outdoor masterpiece. Island frame and finish must be constructed out of non combustible materials and island must be a minimum 18 inches away from any com- bustible surf...
C. Double doors opening 29” wide x 18.25” tall” (allow 3.625” between grill body opening and double doors opening) trim kit bha3803 b. Grill body opening 27.5” wide x 20” deep x 11” tall trim kit bha3802 a-8 build your own island - cutout dimensions d. Searmate opening 12.5” wide x 18” deep x 6.625”...
Lighting instructions reminder: to avoid serious injury, the grill lid must be open before you light the burner. Refer to figure 6. 1. Make sure the propane tank valve and the burner valve are both fully off. 2. Open the grill lid and allow five full minutes to air out. 3. Before each use, inspect t...
A-10 12. After air shutter adjustment, your grill is ready for use – proceed to cooking instructions. 13. If the burner did not light properly, wait 5 minutes before attempting to relight, then repeat steps 1-9 14. If the grill fails to light after the second attempt, call your local lp gas dealer f...
A-11 if you're looking, you're not cooking! Simply close the lid and cook by time. The holland grill has no temperature controls. This means the temperature remains constant; it’s simply a matter of timing. Refer to most any cookbook for the cooking time of an item cooked at the recommended 400 degr...
A-12 grilling chicken 3 lb. Quartered or halves 40-60 minutes total grilling time chicken legs or thighs 45 minutes pork chops 1 inch thick 15 minutes each side steak 3/4 - 1 inch thick 10 - 12 minutes each side italian sausage 40 minutes pork sausage patty 8 minutes each side pork ribs 45 minutes h...
A-13 user serviceable parts model bh421-ss5lpb “apex” 1. Ss5-100w-weld body bottom weld assembly 2. Ss5-200w-weld body top weld assembly 3. Ss5-170-weld control panel mtg brkt 4. Ss5-155c control panel 5. Ss3-251r handle bracket, right 6. Ss3-251l handle bracket, left 7. Ag4-250 handle tube, stainle...
Lp orifice conversion instructions apex models natural gas to lp (propane) gas step 1 close valve at gas supply. Step 2 at the grill, remove on/off knob from gas valve. Step 3 remove the control panel by removing the phillips head screws. Step 4 using 2 wrenches, loosen and remove the supply line fr...
The holland grill company, inc. 121 thomas mill road holly springs, nc 27540 1-800-880-9766 ©the holland grill co., inc. Pn ss5-man-bo version 2012a for more information on our complete line of holland grills and accessories visit us on the web at: www.Hollandgrill.Com ask your dealer to see some of...
The holland grill n0-hassle limited warranty your holland grill, when subjected to normal residential use, is warranted to the original purchaser to be free from factory defects in workmanship and materials. Your holland grill is also guaranteed to perform as advertised during the first 30 days. If ...
Warranty procedure: within 30 days of purchase, send in the warranty card. For on-line warranty service: go to www.Hollandgrill.Com. For personal service: you may also contact the company at 919-557-2001. Please have your model number, serial number and date of purchase available when requesting war...
