1. DL manuals
  2. Jackson Grills
  3. Grill
  4. JLS550-LP
  5. Owner's Manual

Jackson Grills JLS550-LP Owner's Manual

Other manuals for JLS550-LP: Assembly, Use And Care Manual
Manual is about: LUX Series 2 Burner Pedestal

Summary of JLS550-LP

  • Page 1

    1 for cart models: jls700-lp (liquid propane) jls700-ng (natural gas) version: dec13 owner’s manual for lux700 important notice please read all safety notices on pp.3 before assembling or operating this grill..

  • Page 2: Table Of Contents:

    2 table of contents: table of contents: 2 safety warnings: 3 certification & testing; 4 unpacking your grill; parts checklist 4 special message to owners: 5 contact us: 5 owner registration: 5 tools required for assembly: 6 assembling & preparing your grill: 6-7 clearance to combustibles 7 propane g...

  • Page 3: !safety Warnings!

    3 !Safety warnings! Important: please read and understand all warnings and precautions before using your gas grill. 1 this grill is for outside use only, and shall not be used in any home, building, garage, enclosed area or vehicle. 2 this grill is set up from the factory for use with either propane...

  • Page 4: Certification And Testing:

    4 certification and testing: this appliance has been tested by labtest certification inc. (lc), and has been tested to ansi z21.58a-1198 & cga 16a-m98, and certified for canada and the usa. Note: the use and installation of this product must conform to local codes. In the absence of local codes, use...

  • Page 5

    5 special message to our customers: all of us at jackson thank you, for choosing a jackson grill! This appliance was designed, engineered, and built with quality components and we are confident that it will provide you with years of excellent operation. Please take the time to read the entire manual...

  • Page 6

    6 tools required for assembly: please use the proper tools to simplify installation and prevent injury or damage to your grill.  tools included with your grill: 1 x 5mm allen wrench (for casters)  installer supplied tools: 1 x large phillips screwdriver 1 x small phillips screwdriver 1 x small cre...

  • Page 7: Clearance To Combustibles:

    7  prepare rear burner igniter: 1. Unscrew the plastic/rubber cap from the rear burner ignition module, and insert supplied aaa battery with the positive end facing out. (fig. 2) 2. Re-install cap.  install rotisserie kit: 1. Carefully remove the rotisserie kit parts from the packaging. 2. Install...

  • Page 8: Propane Gas Connection:

    8 propane gas connection:  fuel type: the following instructions are for a propane configured grill only. Operating pressure: 11” wc.  hose & regulator: use only the propane hose and regulator supplied with your propane grill.  installation codes: the installation of this appliance must conform w...

  • Page 9: Natural Gas Connection:

    9  connecting the grill to a propane cylinder: 1. Make sure tank valve is in its full off position (turn clockwise to stop). 2. Check tank valve to ensure that is equipped with external (male) threads (i.E. Qcc-1 type connecter). 3. Make sure all burner knobs are in their off position. 4. Remove th...

  • Page 10: Leak Testing:

    10 leak testing:  general: 1. Although all gas connections on the grill are leak tested at the factory, a complete gas tightness check must be performed at the installation site. This is mandatory due to possible mishandling during shipping (which could loosen fittings), or excessive pressure unkno...

  • Page 11: Installer Final Check List:

    11 introducing the island grillstone™ check out this fabulous new way to enhance your cooking! Quarried from natural volcanic rock and then cut into slabs, it is the ideal accessory for grilling veggies, seafood, or marinated meats. Drops right onto your grill! # grillstonesq (14” x 14”) installer f...

  • Page 12

    12 grill lighting instructions: 1. Before lighting: always inspect the gas supply hose before turning the gas “on”. If there is evidence of cuts, wear, or abrasion, it must be replaced before use. Use only a manufacturer approved replacement hose. Check all gas connections for leaks before each use....

  • Page 13

    13 grilling and rotisserie cooking: total gas consumption: total gas consumption per hour, per burner: model jls700 (all): main burners: 15,000 btu/hr. X 4 = 60,000 btu/hr. Rear burner: 13,500 btu/hr. X 1 = 13,500 btu/hr. Total potential consumption: = 73,500 btu/hr.  safety reminders: always leak ...

  • Page 14

    14 2. Using the grilling surface (cook grids): grilling requires high heat for searing and proper browning. Most foods are cooked at the “hi” heat setting for the entire cooking duration. When grilling large pieces of meat or poultry, it may be necessary to turn the heat to a lower setting, after th...

  • Page 15: Cleaning And Maintenance:

    15 cleaning and maintenance: caution: keep the grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids ensure that the grill is completely cold before performing any cleaning and maintenance. Burning off deposits and soiling by turning the main burners o...

  • Page 16

    16 3. Cooking grid cleaning: if the grids are heavily soiled, turn your main burners on high for 10 minutes to burn off excess deposits. (do not run the rotisserie burner with the main burners). After each grilling session, clean the cooking grids with a stainless or brass wire barbecue brush. The b...

  • Page 17: Grill Storage:

    17 5. Interior cleaning: remove the cooking grid, flame diffuser and the burner from the grill. Remove excess residue using a brush, scraper and/or cleaning pad. Spray inside the firebox with oven degreaser and let stand for 5 minutes. Use a toothbrush to loosen up grease and food residues. Wash wit...

  • Page 18: Trouble Shooting:

    18 trouble shooting: a) spider and insect warning: spiders and insects can nest in burners during storage. This can be potentially hazardous, and has been known to cause grill fires. Remove & clean the main burners periodically, and clean them when putting the grill into storage. B) burner inspecion...

  • Page 19: Exploded View: Lux Jls700

    19 exploded view: lux jls700

  • Page 20: Parts List: Lux Jls700

    20 parts list: lux jls700 loc. Description part# (qty.) loc. Description part# (qty.) 01 thermometer bezel jt-11 33 side shelf: right jc-11 02 thermometer jt-10 34 cutting board jc-55 03 hood jh-08 36 side shelf: left jc-10 04 hood handle insulator (black) jh-95 (2) 37 utensil hooks n/a 05 hood hand...

  • Page 21: Limited Lifetime Warranty:

    21 limited lifetime warranty: model no: lux jls700-lp & jls700-ng cart type jackson grills warrants the following materials and workmanship to be free of defects for as long as you own the grill subject to the conditions below: first 5 years: (from date of purchase); jackson grills will replace or r...