Summary of 570-DZR1200X1
Page 1
Mono block amplifier owner’s manual 570-dzr600x1 570-dzr1200x1.
Page 2: Introduction:
Introduction: congratulations on your new purchase of kaption audio amplifier. These amplifiers are engineered to reproduce music that is so detailed, you will hear music in a whole new truly superior product. We always recommend you have these amplifiers installed by an authorized kaption audio dea...
Page 3: Pre- Installation
W arning i nvestigate the layout of your automobile thoroughly before drilling or cutting any holes . U se extreme care when you work near the gas tanks , gas or hydraulic lines , and electrical wiring . A lways make sure the a mplifier is securely mounted . M ounting the a mplifier securely to the ...
Page 4: 570-Dzr600X1 Parts List
570-dzr600x1 parts list • 600w mono block amplifier • wired bass remote control • high level-in wire adapter • hardware pack 570-dzr1200x1 parts list • 1200w mono block amplifier • wired bass remote control • hardware pack 193 7.58 61 2.40 8.74 222 154 6.06 2 1 3 4 7 8 12 13 11 10 9 6 5 352 13.84 61...
Page 5: 1. Speaker Terminals
Controls and wiring locations 1. Speaker terminals terminals outputs to amplifier. See wire diagrams for the type of sub- woofer the amplifier will be connected to. 2. +12 volt power connection. Th amplifier must be connect to the positive terminal on the vehicle’s battery. A fuse must be connected ...
Page 6: 5. Subsonic Filter
5. Subsonic filter the subsonic is adjustable to filter out undesirable low frequencies from 10hz to 50hz. 6. Lpf (low pass filter) control the lpf controls the low pass crossover to select the desired frequency. The frequency can be adjusted from 40hz to 220hz. 7. Gain control use the gain control ...
Page 7: 10. Rca Input Jacks
10. Rca input jacks rca input jacks are for use with source units output signal. Source units with an output signal level of minimum 200mv may be used. (see wiring diagrams) 11. Wired bass remote jack provides a wired remote control to the drivers seated location. The bass remote controls the amplif...
Page 8
Use the high level output from the source unit and the high level-in adapter supplied with the amplifier. Splice the source unit speaker wires to high level-in adapter’s terminal block on the adapter. Be sure to connect the car audio’s system (+) wiring to the terminal block (+) and the (-) car audi...
Page 9
Model 570-dzr600x1 570-dzr1200x1 cable size 4ga awg 4 - 2ga awg fuse 60 amps 150 amps • rem (item 3): this connection turns the amplifier on and off with a low level input. Connect the rem to the source unit’s remote-turn-on output. If the source unit does not have a remote-turn-on circuit the ampli...
Page 10: Speaker Wiring Diagram
Fuse source unit fuse source unit speaker wiring diagram single woofer setup - 9 - mono block amplifiers.
Page 11: Dual Woofer Setup
Fuse source unit fuse source unit dual woofer setup - 10 - mono block amplifiers.
Page 12: Troubleshooting Guide
Troubleshooting guide problem causes and solutions power indicator is not lit a. Check +12 volt wire fuse blown and replace if needed b. Check remote turn on +12v and gnd connections ensure the ground is secured to clean metal on the vehicle chassis. C. Source unit not functioning properly power ind...
Page 13: Specifications
Specifications model 570-dzr600x1 570dzr1200x1 description 600w mono block 1200w mono block continuous power @ 14.4v 1Ω load n/a 1800w rms 2Ω load 600w rms 1000w rms 4Ω load 400w rms 650w rms features minimum load 2 ohm 1 ohm low input level 0.2 ~ 5v high input level 0.4 ~ 10v n/a frequency response...
Page 14: What Is Not Covered
Limited warranty information: kaption audio amplifiers have a one-year limited warranty. This warranty covers the original purchaser of a kaption audio speaker, purchased from an authorized kaption audio dealer. In order to receive service, proof of purchase is required stating the customers name, d...
Page 15: Warranty Registration Card
Warranty registration card name: ________________________________________________ street: ________________________________________________ city: ________________________________________________ province / state: ________________________________________________ country: ______________________________...
Page 16: Kaption Audio
Kaption audio 95 cousins drive aurora, ontario canada, l4g 1b5 www.Kaptionaudio.Com 866-kaption (527-8466) designed in canada; made in china r0 (04/15).