Katsu Power DCA 22 Owner's Manual - page 2
6
STORAGE
Unscrew the drain plug to allow all the water in the pump to drain out.
Make sure the pump is empty before replacing the drain plug.
Storage
When pump is out of service for long periods, drain it and store in a dry,
and well ventilated room.
Pull engine cord until compressed time so valves are sealed (Never run
pump dry for more than half a minute or mechanical seal may be damaged).
Warning
To avoid a fire, make sure that the engine is cool before transportation or
storage.
Transport the pump with the fuel cock turned off, besides, keep it horizontal
position to prevent spilling.
1
2
3
The storage place should be dry and free of humidity.
Clean the water pump inside. If the pump is used to pump water with mud,
sand or heavy debris, deposit of that material may remain inside it.
Empty fuel inside the fuel tank.
Set the fuel cock to OFF, unscrew the fuel drain plug of the carburetor
floater room, drain out the fuel in the carburetor. Hold drained gasoline in
a proper container.
Set the fuel cock to ON.
Reinstall the fuel drain plug of the carburetor floater room
Remove the engine oil.
Pull the starter handle towards until resistance is felt, and then continue
pulling until the triangle mark on the starter wheel lines up with the starter
screw hole. In this location, both the air inlet and exhaust valves are
closed.
Triangle mark on the starter wheel lines up with the starter screw hole.
The self-priming DCA Series pumps are designed to operate efficiently for
O W N E R M A N U A L D C A K AT S U P O W E R W AT E R P U M P S
O W N E R M A N U A L D C A K AT S U P O W E R W AT E R P U M P S
!
CAUTION
The engine must be filled with oil before starting, don’t forget to read engine
manual for this procedure.
Do not use pump in explosive atmosphere, Do not pump volatile or flammable
liquids.
Draining: During freezing temperature weather, be sure to drain pump when
it is not in use.
Reinstall the fuel drain plug
+
+
+
+
+
14
15
Unscrew the drain plug
Close the fuel cock (set to
OFF
)
+