Katsu Power DCA 22 Owner's Manual - page 7
+
+
Engine oil alarm system (installation location)
The engines oil alarm system was designed to avoid engine damage due to
oil low level in the crankcase. Before the engine oil level in the crankcase
drops down below the safety line, the alarm system will stop the engine
automatically (while the engine switch is ON).
If the engine stops and cannot restart, check the engine oil level.
Remove the engine oil dipstick and wipe it clean; insert into engine oil
filler hole without screwing it in, and then take out to check the engine oil
level; if the engine oil level is too low, fill specified engine oil up to the
top of the filler hole.
Engine fuel level check.
Remove the fuel tank cap and check the fuel level. If the fuel level is too
low, refuel it.
Only use specified gasoline or use clean fresh Lead-free gasoline with a
minimun of 77 octane. Leaded gasoline may be used if it is commercially
available and if unleaded 15 unavailable.
Do not use the combination of engine oil and gasoline or filthy gasoline.
Avoid dirt, dust and water into the fuel tank.
Fuel tank capacity: 3.6 lts
+
10
Fill the engine check
Engine oil level check
Upper level mark
Warning
Never clean the air cleaner in gasoline or low-flash point solvent, for
gasoline and low-flash point solvent may produce flames and even an
explosion in certain conditions.
C a u t i o n
Never operate the water pump without the air cleaner installed. In the case
that dirt and dust is sucked into the engine, the engine will wear out more
quickly.
Unscrew the thumbnut and dismantle the air cleaner cover and filter
element.
Clean the filter element in high flash point solvent or cleansing solvent
thoroughly, and then dry it up.
Soak the filter element in clean engine oil, and then squeeze out excessive
oil.
Reinstall the removed parts well.
Spark plug maintenance
Spark plug recommended: NHSP LD F6RTCU
To keep the engine in good condition, you must keep proper spark plug
clearance and no accumulated carbon.
Dismantle the spark plug cap.
2
+
+
+
+
+
+
3
19
Dismantle the air cleaner cover
and filter element
O W N E R M A N U A L D C A K AT S U P O W E R W AT E R P U M P S
O W N E R M A N U A L D C A K AT S U P O W E R W AT E R P U M P S