Katsu Power DCA 22 Owner's Manual - page 5
Note
Use in extremely dusty area, the job should be done more often.
Should be done by your dealer, unless you are equipped with proper repair
tools, and are proper trained and are qualified.
Engine oil replacement
A warm-up engine can assure quick oil draining.
Remove the dipstick and oil drain plug, and then drain the oil.
Reinstall the dipstick and tighten it.
Fill specified fresh engine oil to oil level mark.
Oil capacity: 0.6 lts
Note
Handle discarded engine oil in accordance with the local environmental
protection rules.
Air Cleaner Maintenance
A filthy air cleaner will decrease airflow quantity through the carburetor.
To avoid carburetor troubles, clean the air cleaner regularly. In extremely
dusty area, the job should be done more often.
1
+
+
+
2
18
Remove the dipstick
Fill specified engine oil
Air cleaner filter element check
Dismantle the thumbnut, washer and air cleaner cover.
Check the filter element, if too filthy or clogged, clean it.
!
CAUTION
Gasoline is extremely inflammable and explosive in certain conditions
Refuel in a well-ventilated area with the engine stopped. Do not allow flames
or sparks in the storage area.
Do not spill fuel out of the fuel tank, after refueling make sure to tighten the
fuel tank cap securely.
If the gasoline was spilled, be sure to wipe it dry before starting the engine.
.
S t a r t u p
S t a r t i n g u p
Open the fuel cock (set it at ON)
Close the choke.
NOTE
Starting up under high air temperature or in warm engine, do not use the
choke, don't close it before starting up.
Set the engine switch at ON
Move the throttle valve level slowly to the left.
Pull the start handle gently until resistance is felt, and then pull it up
quickly.
1
2
3
4
5
Set the engine
switch at ON
11
Move the throttle valve to the left
Pull the start handle
Close the fuel cock (set to
ON
)
O W N E R M A N U A L D C A K AT S U P O W E R W AT E R P U M P S
O W N E R M A N U A L D C A K AT S U P O W E R W AT E R P U M P S