Multisided top/rear vent convertible direct vent fireplaces homeowner’s installation and operating manual ,/ design certified 10006326 1/13 rev. 8 installer: leave this manual with the appliance. Consumer: retain this manual for future reference. Do not store or use gasoline or other flammable vapor...
2 360 dvs series direct vent fireplaces 10006326 installation and operating instructions ........................................................................................................3 important curing/burning instructions ......................................................................
3 360dvs series direct vent fireplaces 10006326 this gas appliance should be installed by a qualified installer, preferably nfi or wett (canada) certified, in accordance with local building codes and current csa-b149.1 installation codes for gas burning appliances and equipment. If the unit is being...
4 360 dvs series direct vent fireplaces 10006326 requirements for the commonwealth of massachusetts all gas fitting and installation of this heater shall only be done by a licensed gas fitter or licensed plumber. For all side wall horizontally vented gas fueled equipment installed in every dwelling,...
5 360dvs series direct vent fireplaces 10006326 j j k k h d a e b i e a f c h 6326 360dvs2 top vent specs electrical access gas line access electrical access gas line access k j j k j j g j j k k h d a e b e a f c k h 6326 360dvs2 rear vent specs g i electrical access gas line access electrical acce...
6 360 dvs series direct vent fireplaces 10006326 i j k k rod 6326 360dvs3 rear vent specs b e c g f d a h h b electrical access gas line access c k j j i j k k 6326 360dvs3 top vent specs b e c f d a h h b electrical access gas line access k j j g fireplace dimensions - 360dvs3 / 306dvsl / 360dvsr r...
7 360dvs series direct vent fireplaces 10006326 roh rod row cfm121 360dvs2 rear vent configuration 8/10/00 framing dimensions - 360dvs2 cfm122 360dvs2 - top vent configuration 8/10/00 rod roh row rear vent configuration top vent configuration cfm121 cfm122 framing dimensions ref. Rear vent configura...
8 360 dvs series direct vent fireplaces 10006326 cfm123_360dvs3_dims_rv2 rear vent configuration 8/10/00 rev. 8-23-02 rjs rod row rod roh roh roh rod 360dvsl 360dvs/3/l/r 360dvs3 360dvsr cfm124_360dvs3_tv2 top vent configuration 8/10/00 rev. 8-23-02 rjs rod rod roh row roh roh rod 360dvsl 360dvs/3/l...
9 360dvs series direct vent fireplaces 10006326 top of unit to ceiling ................................. 36” (914 mm) front of unit to combustibles ................... 36” (914 mm) appliance top .........................................0” (0 mm) to standoff bottom ......................................
10 360 dvs series direct vent fireplaces 10006326 a hearth is not mandatory; however, for aesthetic purposes, we recommend installing a noncombustible hearth that projects out 12” (305mm) or more from the front of the fireplace. Cold climate installation recommendation: when installing this unit aga...
11 360dvs series direct vent fireplaces 10006326 fp297a insta vent free uvhb26 gas supply 7/1/98 1/2” gas supply 1/2” npt x 1/2” flare shut-off valve 3/8” flex line (from valve) fp297a fig. 5 gas shutoff valve and flex connector. When using copper or flex connector, use only ap- proved fittings. Alw...
12 360 dvs series direct vent fireplaces 10006326 fp1430 fig. 8 alternate switch location. Optional top vent application this appliance is shipped as a rear vent unit. If the installation layout requires the unit to be a top vent con- figuration, the appliance can be converted by following the steps...
13 360dvs series direct vent fireplaces 10006326 electronic gas control valve this appliance may be fitted with a honeywell ignition module. Installation of the remote on/off starter switch on electronic ignition units (fig. 12): 1. Thread the wiring through the holes on the side panels of the appli...
14 360 dvs series direct vent fireplaces 10006326 v v v v v v v x x x d e b b b c b m b a j k f l vent termination air supply inlet area where terminal is not permitted h i Ýi` Ãi` operable operable fixed closed v b cfm145a dv termin location 5/01/01 rev. 12/05/01 sta inside corner detail v a g n...
15 360dvs series direct vent fireplaces 10006326 fig. 14 termination clearances. General information assembling vent pipes canadian installations: venting system must be installed in accordance with the current csa-b149.1 installation code. Usa installations: the venting system must conform with loc...
16 360 dvs series direct vent fireplaces 10006326 how to use the vent graph the vent chart should be read in conjunction with the following vent installation instructions to determine the relationship of the vertical and horizontal dimensions of the vent system. 1. Determine the height of the center...
17 360dvs series direct vent fireplaces 10006326 vo584-100 vent opening 2/99 djt vent opening for combustible wall 9 ³⁄₈ ” (240mm) 10 ³⁄₈ ” (265mm) framing detail vent opening for noncombustible wall 7 ¹⁄₂ ” (190mm) vo584-100 fig. 18 locate vent opening on rear wall. Step 3 measure the horizontal le...
18 360 dvs series direct vent fireplaces 10006326 horizontal plane means no vertical rise exists on this portion of the vent assembly. • the maximum number of 90˚ elbows per side wall installation is three (3). • if a 90˚ elbow is fitted directly on top of the fireplace flange, the maximum horizonta...
19 360dvs series direct vent fireplaces 10006326 step 3 place fireplace into position. (fig. 26) measure the verti- cal height (x) required from the base of the flue collars to the center of the wall opening. Vo584-100 vent opening 2/99 djt vent opening for combustible wall 9 ³⁄₈ ” (240mm) 9 ³⁄₈ ” (...
20 360 dvs series direct vent fireplaces 10006326 2” (51 mm). Secure termination to the wall with screws provided, and caulk around the wall plate to weather- proof. One alternative to screwing the termination directly to the wallis the use of expanding plugs or an approved exterior construction adh...
21 360dvs series direct vent fireplaces 10006326 vertical through-the-roof application this gas fireplace has been approved for: • vertical installations up to 40’ (12 m) in height. Up to a 10’ (3 m) horizontal vent run can be installed within the vent system using a maximum of two 90° elbows. (fig....
22 360 dvs series direct vent fireplaces 10006326 vertical through-the-roof installation 1. Locate your fireplace. 2. Plumb to center of the (4”) flue collar from ceiling above and mark position. 3. Cut an opening equal to 9 ³⁄₈ ” x 9 ³⁄₈ ” (240 x 240mm). 4. Proceed to plumb for additional openings ...
23 360dvs series direct vent fireplaces 10006326 584b vent components starter kit 2/25/99 djt 584g venting components firestop spacer 2/25/99 djt 584h venting components attic insulation shield 2/25/99 djt 584i vent components offset support 2/25/99 djt 584f venting components pipe sections 2/25/99 ...
24 360 dvs series direct vent fireplaces 10006326 operating instructions only glass approved by vermont castings group should be used on this fireplace. Glass information • the top side and top end louvres are removed by simply lifting the louvre assembly and pulling the assembly away from the firep...
25 360dvs series direct vent fireplaces 10006326 glass cleaning it is necessary to periodically clean glass. During start- up, condensation, which is normal, forms on the inside of the glass. This condensation causes lint, dust and other airborne particles to cling to glass surface. Also initial pai...
26 360 dvs series direct vent fireplaces 10006326 lg320 360dvs logs b120 b121 b122 b123 b124 b126 b125 lg320 fig. 40 360dvs log placement. Side of fireplace venting side venting side lg321 360dvs logs opposite side b120 b121 b122 b123 b126 b125 side of fireplace lg321 fig. 41 360dvs log placement. L...
27 360dvs series direct vent fireplaces 10006326 lo hi fp390 flame adjustment knob 11/21/96 turn counterclockwise to increase flame height turn clockwise to decrease flame height fig. 43 flame adjustment knob for sit valve. Flame characteristics it is important to periodically perform a visual check...
28 360 dvs series direct vent fireplaces 10006326 1. Stop! Read the safety information above. 2. Turn off all electrical power to the fireplace. 3. For mn/mp/tn/tp appliances only, go on to step 4. For rn/rp appliances turn the on/off switch to “off” position or set thermostat to lowest level. 4. Op...
29 360dvs series direct vent fireplaces 10006326 lighting and operating instructions for fireplaces equipped with sit822 gas valve (en or ep) a. This fireplace is equipped with an ignition device which automatically lights the pilot. Do not try to light the pilot by hand. B. Before operating , smell...
30 360 dvs series direct vent fireplaces 10006326 note: before troubleshooting the gas control system, be sure external gas shut off is in the “on” position. Sit nova 820 millivolt valve troubleshooting the gas control system warning: remove glass front before doing any gas control service work. Sym...
31 360dvs series direct vent fireplaces 10006326 sit 822 valve with a honeywell electronic igniter note: remove glass before servicing. Start turn gas supply off. Turn on/off switch to call for heat. Power to module? (24v normal) spark across ignitor sensor gap? Yes yes yes turn gas on. Pilot burner...
32 360 dvs series direct vent fireplaces 10006326 troubleshooting – honeywell vs8421 start check gas supply on pilot lights with piezo ignitor • lockout has engaged. Wait 60 seconds and try again. • for spark at electrode while depressing piezo 1/8" gap to pilot hood needed. • all wiring connections...
33 360dvs series direct vent fireplaces 10006326 fuel conversion instructions to convert this appliance from gas type to another, fol- low these instructions. Before proceeding, turn control knob to “off” and turn gas supply off . Turn off any electricity that may be going to the appliance. Caution:...
34 360 dvs series direct vent fireplaces 10006326 d e f fc108 sit regulator conversion 10/03 off pilot on fc108 fig. 49 replace regulator. 10. Reassemble fireplace in the reverse order, except for the window frame assembly. Leave this off until after unit has been checked for leaks and the gas suppl...
35 360dvs series direct vent fireplaces 10006326 burner and burner compartment it is important to keep the burner and the burner com- partment clean. At least once per year remove the logs and lava rock/ember material. Vacuum and wipe out the burner compartment. Remove and refit the logs per the ins...
36 360 dvs series direct vent fireplaces 10006326 lo hi pilo t adj pilot on off 4a/b 5a/b 6 11 9 11 8 10 7 12 18 24 27 17 2 29 28 22 23 26 21 20 25 19 13 14 3a/b 15a/b 16a/b 6326 360dvs parts 31a/b 32 35 33 hi lo 34a/b 25 36 37 30 1 1a 1b 1c 1d 1e 1f 1g vermont castings group reserves the right to m...
37 360dvs series direct vent fireplaces 10006326 360dvs series (items marked ‘*’ are not shown in the parts illustration) ref. Description 360dvs2 360dvs3 360dvsl 360dvsr 1. Log set (complete) 10006350 10006350 10006350 10006350 1a. Log - rear (b120) 10006315 10006315 10006315 10006315 1b. Log - fro...
38 360 dvs series direct vent fireplaces 10006326 ref. Description 360dvs2 360dvs3 360dvsl 360dvsr 360dvs series (continued) (items marked ‘*’ are not shown in the parts illustration) 21. Louvre assembly, side bottom 10000040 10000040 10000040 10000040 22. Louvre assembly, end top n/a 10002411 10002...
39 360dvs series direct vent fireplaces 10006326 optional accessories fan kits fk24 fan assembly this auxiliary fan system increases the efficiency of the circulation of the heated air. The fk24 fan kit allows variable speed control of the circulation fan and also incorporates a heat sensor in the c...
40 360 dvs series direct vent fireplaces 10006326 wiring instructions the fireplace, when installed, must be electri- cally connected and grounded in accordance with local codes, or in the absence of local codes, with the current csa c22.1 canadian electric code. For usa installations, follow local ...
41 360dvs series direct vent fireplaces 10006326.
42 360 dvs series direct vent fireplaces 10006326.
43 360dvs series direct vent fireplaces 10006326 lifetime warranty the following components are warranted for life to the original owner, subject to proof of purchase: firebox, combus- tion chamber, heat exchanger, grate and stainless steel burners. Five year warranty the following components are wa...
Efficiency ratings model energuide ratings steady state (%) d.O.E. Fireplace efficiency (%) fan-off fan-on (afue%) 360dvs2rn 62.4 83 84 65 360dvs2rp 62.4 83 84 65 360dvs2en 62.4 83 84 65 360dvs2ep 62.4 83 84 65 360dvs3rn 62.4 83 84 65 360dvs3rp 62.4 83 84 65 360dvs3en 62.4 83 84 65 360dvs3ep 62.4 83...