1. DL manuals
  2. Quadra-Fire
  3. Wood stove
  4. MTV-E2-CSB
  5. Installation Manual

Quadra-Fire MTV-E2-CSB Installation Manual

Summary of MTV-E2-CSB

  • Page 1

    1 7080-131d october 28, 2014 mt. Vernon e2 pellet stove model(s): mtv-e2-csb mtv-e2-mbk mtv-e2-pft mtv-e2-pdb mtv-e2-pbk mtv-e2-pmh installation manual installation & appliance set-up installer: leave this manual with party responsible for use and operation. Owner: retain this manual for future refe...

  • Page 2

    2 7080-131d october 28, 2014 mt vernon e2 table of contents safety alert key: • danger! Indicates a hazardous situation which, if not avoided will result in death or serious injury. • warning! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • caution! I...

  • Page 3

    October 28, 2014 7080-131d 3 mt vernon e2 the quadra-fire mt. Vernon e2 pellet stove meets the u.S. Envi- ronmental protection agency’s 1990 particulate emission standards. 1 important safety information note: hearth & home technologies, manufacturer of this appliance, reserves the right to alter it...

  • Page 4: Install Guide

    4 7080-131d october 28, 2014 mt vernon e2 install guide 2 getting started marginal location: • below peak location not recommended: • not the highest point of the roof • wind loading possible multi-level roofs windward leeward recommended: outside air intake on windward side not recommended: outside...

  • Page 5

    October 28, 2014 7080-131d 5 mt vernon e2 • installation and use of any damaged appliance. • modifi cation of the appliance. • installation other than as instructed by hearth & home technologies. • installation and/or use of any component part not approved by hearth & home technologies. • operating ...

  • Page 6

    6 7080-131d october 28, 2014 mt vernon e2 attention installer: follow this standard work checklist this standard work checklist is to be used by the installer in conjunction with, not instead of, the instructions contained in this installation manual. Customer: date installed: lot/address: location ...

  • Page 7

    October 28, 2014 7080-131d 7 mt vernon e2 figure 7.4 - front view figure 7.1 - top view with top vent adapter and 3 to 6 in (76-152mm) adapter figure 7.5 - side view figure 7.2 - side view with top vent adapter and 3 to 6 in (76-152mm) offset adapter. 31-1/16 [788] 29-3/16 [741] q 5-13/16 [147] 2-9/...

  • Page 8

    8 7080-131d october 28, 2014 mt vernon e2 straight back against wall inches millimeters a back wall to appliance 2 51 b side wall to appliance 6 152 corner installation inches millimeters c walls to appliance 2 51 vertical installation inches millimeters d back wall to flue pipe 3 76 e side wall to ...

  • Page 9

    October 28, 2014 7080-131d 9 mt vernon e2 c a b d note: • illustrations refl ect typical installations and are for design purposes only. • i llustrations/diagrams are not drawn to scale. • actual installation may vary due to individual design preference. D. Alcove figure 9.1 *all minimums listed are...

  • Page 10

    10 7080-131d october 28, 2014 mt vernon e2 4 vent information a. Venting termination minimum requirements j or k x v m i h a v g b v v a b v f v c b b e l v d v electrical service v n v n v n n v inside corner fixed closed open open fixed closed v x g g termination cap air supply inlet gas meter res...

  • Page 11

    October 28, 2014 7080-131d 11 mt vernon e2 b. Avoiding smoke and odors negative pressure, shut-down and electrical power failure to reduce the probability of back-drafting or burn-back in the pellet appliance during power failure or shut down con- ditions, it must be able to draft naturally without ...

  • Page 12

    12 7080-131d october 28, 2014 mt vernon e2 c. Negative pressure negative pressure results from the imbalance of air avail- able for the appliance to operate properly. It can be strongest in lower levels of the house. Causes include: • exhaust fans (kitchen, bath, etc.) • range hoods • combustion air...

  • Page 13

    October 28, 2014 7080-131d 13 mt vernon e2 f. Equivalent feet of pipe the table below can help you calculate the equivalent feet of pipe which is a method used to determine pellet vent size. Figure 13.1. 2 ft. 2 ft. 3 ft. 2 ft. Example of 3 elbow-rear vent termination calculation pellet venting comp...

  • Page 14

    14 7080-131d october 28, 2014 mt vernon e2 2 in [51mm] min 6 in [152mm] min 6 in [152mm] min non-combustible hearth pad wall thimble horizontal termination cap straight out figure 14.1 figure 14.2 wall thimble illustration shows venting going in both directions. Choose which one is best for your ins...

  • Page 15

    October 28, 2014 7080-131d 15 mt vernon e2 c. Through the wall & vertical - exterior firestop flashing rain cap 6 in [152mm] min non-combustible hearth pad 3 in [76mm] min clean-out cover 12 in. [305mm] min ceiling support 3 to 6 in [76 to 152mm] offset adapter 6 in. [152mm] class a chimney connecto...

  • Page 16

    16 7080-131d october 28, 2014 mt vernon e2 e. Masonry f. Alternate masonry concrete cap non-combustible hearth pad 6 in [152mm] min airtight clean-out door sheathing 1 in [25mm] clearnance 2 in [51mm] min to combustible material flashing fireclay flue liner with airspace 1 in [25mm] clearance with f...

  • Page 17

    October 28, 2014 7080-131d 17 mt vernon e2 6 appliance set-up figure 17.3 - bolt fully extended figure 17.2 figure 17.1 a. Leg leveling system 1. Thread allen bolts through nuts until fl ush. Figure 17.1. The allen bolts and nuts are included in the component pack inside the appliance fi rebox. 2. S...

  • Page 18

    18 7080-131d october 28, 2014 mt vernon e2 3 in. To 6 in. Offset adapter silicone rear exhaust outlet 3 in. To 3 in. Top vent adapter clean-out cover drill hole, 1 on each side c. Top vent adapter installation 3 to 3 inch (76-76mm) top vent adapter 3 to 6 inch (76-152mm) top vent offset adapter inst...

  • Page 19

    October 28, 2014 7080-131d 19 mt vernon e2 caution logs are fragile. Use extreme care when handling or cleaning logs. Notice: due to the abrasive nature of a pellet appliance fi re, the logs are not covered under warranty. Any placement variation other than shown here can cause excessive heat and sh...

  • Page 20

    20 7080-131d october 28, 2014 mt vernon e2 f. Remote thermostat installation 1. When mounting the thermostat on the wall, be sure to follow your remote thermostat’s installation instructions carefully. Note: the remote thermostat should be mounted on an inside wall and not in direct line with the ap...

  • Page 21

    October 28, 2014 7080-131d 21 mt vernon e2 7 mobile home installation you must use a quadra-fire outside air kit for installation in a mobile home. 1. An outside air inlet must be provided for the combustion air and must remain clear of leaves, debris, ice and/or snow. It must be unrestricted while ...

  • Page 22

    22 7080-131d october 28, 2014 mt vernon e2 8 accessory list accessories collar, offset, top vent 812-3570 damper, 3 inch - tall vertical installs only pel-damp3 y damper, 4 inch - tall vertical installs only pel-damp4 firescreen no longer available scr-7005 log set, (sold as set only) 2 pc logs-60-a...

  • Page 23

    October 28, 2014 7080-131d 23 mt vernon e2.

  • Page 24

    24 7080-131d october 28, 2014 do not discard this manual caution • important operating and maintenance instruc- tions included. • leave this manual with party responsible for use and operation. • read, understand and follow these instruc- tions for safe installa- tion and operation. Do not discard c...