- DL manuals
- Ransomes
- Lawn Mower
- HIGHWAY 2130
- Parts And Maintenance Manual
Ransomes HIGHWAY 2130 Parts And Maintenance Manual
HIGHWAY 2130
RJ 100 / 052003
AVERTISSEMENT : Risque de blessures graves en cas
d’utilisation incorrecte de la machine. Les opérateurs et le
personnel d’entretien doivent être formés et conscients des
dangers encourus. Ils doivent lire avec attention le manuel
avant d’essayer de monter, d’utiliser, de régler ou maintenir la
machine.
24285G-FR (rev.6)
Series: WJ - Engine type: KUBOTA V1305
2WD Product codes: LGEA070
Series: CS - Engine type: FORD VSG413
2WD Product codes: LGEA200
Series: CU - Engine type: KUBOTA V1305
4WD Product codes: LGEA100
Series: DK - Engine type: FORD VSG413
4WD Product codes: LGEA400
WARNING: If incorrectly used this machine can cause severe
injury. Those who use and maintain this machine should be
trained in its proper use, warned of its dangers and should
read the entire manual before attempting to set up, operate,
adjust or service the machine.
Parts and Maintenance Manual
Nomenclature Des Pieces De Rechange
& Manuel De Maintenance
Summary of HIGHWAY 2130
Page 1
Highway 2130 rj 100 / 052003 avertissement : risque de blessures graves en cas d’utilisation incorrecte de la machine. Les opérateurs et le personnel d’entretien doivent être formés et conscients des dangers encourus. Ils doivent lire avec attention le manuel avant d’essayer de monter, d’utiliser, d...
Page 2
© 2003, ransomes jacobsen limited. All rights reserved.
Page 3
Gb-1 gb ransomes highway 2130 maintenance and parts manual 1 contents 2 introduction 2.1 product identification .......................................................................................... 2 2.2 spares stocking guide ........................................................................
Page 4
Gb-2 ransomes highway 2130 maintenance and parts manual gb 2 introduction 2.2 spares stocking guide to keep your equipment fully operational and productive, ransomes suggests you maintain a stock of the more commonly used maintenance items. We have included part numbers for the additional support ma...
Page 5
Gb-3 gb ransomes highway 2130 maintenance and parts manual 2 introduction 2.3 how to use the parts manual item number each part which is identified in the illustrations has an item number. Parts which do not have an item number may not be readily identified in the illustration but are usually closel...
Page 6
Gb-4 ransomes highway 2130 maintenance and parts manual gb 3 safety instructions this safety symbol indicates important safety messages in this manual. When you see this symbol, be alert to the possibility of injury, carefully read the message that follows, and inform other operators. 3.1 operating ...
Page 7
Gb-5 gb ransomes highway 2130 maintenance and parts manual 3 safety instructions 3.7 slopes take extra care when working on slopes • local undulations and sinkage will change the general slope. Avoid ground conditions which can cause the machine to slide. • keep machine speeds low on slopes and duri...
Page 8
Gb-6 ransomes highway 2130 maintenance and parts manual gb danger - indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. Warning - indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. Caution...
Page 9
Gb-7 gb ransomes highway 2130 maintenance and parts manual 3 safety instructions california proposition 65 engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the state of california to cause cancer and birth defects or other reproductive harm....
Page 10
Gb-8 ransomes highway 2130 maintenance and parts manual gb 4 specifications 4.1 engine specification 4.1.1 diesel type: kubota 25kw @ 3000rpm, 4 cylinder (in-line) vertical diesel engine, 4-stroke, water cooled, 1335cc, with 12v electric start. Model: v1305-bbs-ec-1 maximum speed: 3150 ± 50 rpm (no ...
Page 11
Gb-9 gb ransomes highway 2130 maintenance and parts manual 4 specifications e r u t a r e p m e t y t i s o c s i v l i o ) f ° 9 3 ( c ° 4 e v o b a 0 3 e a s ) f ° 9 3 ( c ° 4 w o l e b 0 3 - w 0 1 r o 0 3 - w 5 e a s 0 3 1 2 y a w h g i h k d / s c / u c / j w s e i r e s n o i t a r e l e c c a ...
Page 12
Gb-10 ransomes highway 2130 maintenance and parts manual gb 5 lubrication and maintenance 5.1 lubrication and maintenance chart deisel powered machines s e r u d e c o r p e c n a n a t n i a m p o h s k r o w e r a s t n i o p t e l l u b e t i h w y l i a d / y l k e e w y r e v e s r u o h 0 4 t ...
Page 13
Gb-11 gb ransomes highway 2130 maintenance and parts manual s e r u d e c o r p e c n a n a t n i a m p o h s k r o w e r a s t n i o p t e l l u b e t i h w y l i a d / y l k e e w y r e v e s r u o h 0 4 y r e v e 0 0 2 s r u o h y r e v e 0 0 4 s r u o h y r e v e 0 0 8 s r u o h d n e f o n o s ...
Page 14
Gb-12 ransomes highway 2130 maintenance and parts manual gb 5 lubrication and maintenance 5.3 engine - diesel: first 50 working hours and every 200 working hours. Change engine oil. (a) warm up the engine first and then shut it off. Remove oil drain plug from the bottom of the crankcase and wipe it ...
Page 15
Gb-13 gb ransomes highway 2130 maintenance and parts manual 5.4 machine: lubricate the following points.Weekly or every 40 working hours. 1. Lubricate the following with shell darina r2 grease. (a) lift arm pivots (a). (b) cutting unit pivots (b). (c) axle centre pivot (c). (d) axle stub shaft pivot...
Page 16
Gb-14 ransomes highway 2130 maintenance and parts manual gb 5.6 machine: every 800 working hours. Change hydraulic oil. 1. Remove drain plug in bottom of hydraulic tank and wipe off plug. 2. Allow tank to drain and replace plug. 3. Refill tank with 35 litres of shell tellus 46 oil. Important-wheneve...
Page 17
Gb-15 gb ransomes highway 2130 maintenance and parts manual 5.8 engine maintenance - diesel every 100 hrs fuel system. Use diesel fuel no.2-d (astm d975) see engine manufacturer's manual for additional information. Water separator - if water is not removed from the fuel, extensive damage can be done...
Page 18
Gb-16 ransomes highway 2130 maintenance and parts manual gb 5.9 engine maintenance - diesel every 400 hrs replace in-line fuel (c) cleaning the air filter remove loose dirt from element with compressed air working from the clean to dirty side, using compressed air max 6 bar , with nozzle 5cm from el...
Page 19
Gb-17 gb ransomes highway 2130 maintenance and parts manual other regular service. • verify proper operation of safety interlock switches (parking brake, seat switch, etc.) • ensure nuts and bolts remain tight. • keep tyre pressure at 1kg/cm 2 (14psi). • follow the engine manufacturer’s maintenance ...
Page 20
Gb-18 ransomes highway 2130 maintenance and parts manual gb 5 lubrication and maintenance 5.12 end of season or when required change hydraulic filter. 1. Lower the centre cutting unit to improve access. 2. Wipe filter bowl (a) and housing to remove any dirt present. 3. Place a suitable drip tray on ...
Page 21
Gb-19 gb ransomes highway 2130 maintenance and parts manual 5 lubrication and maintenance maintenance 5.12.1 end of season or when required lpg engine change spark plugs 1. Remove the lead from each spark plug by grasping, twisting and then pulling the moulded boot on the end of the lead. 2. After l...
Page 22
Gb-20 ransomes highway 2130 maintenance and parts manual gb 6.1 speed limiter. The transport and mow speeds of the machine are factory set and should not be altered. Textron turf care cannot be held responsible for loss of performance or machine damage if these speeds are altered. Adjustments 6.2 al...
Page 23
Gb-21 gb ransomes highway 2130 maintenance and parts manual ransomes jacobsen grinding paste: 80 grit grinding paste, 4.5kg tin, part number 5002488 120 grit grinding paste, 4.5kg tin, part number 5002489 80 grit grinding paste, 9kg tin, part number 5002490 120 grit grinding paste, 9kg tin, part num...
Page 24
Gb-22 ransomes highway 2130 maintenance and parts manual gb 7.1 troubleshooting - diesel the troubleshootijng chart below lists basic problems that may occur during start-up and operation. For more detailed information regarding the hydraulic and electrical systems contact your area ransomes distrib...
Page 25
Gb-23 gb ransomes highway 2130 maintenance and parts manual 7 troubleshooting 7.1 troubleshooting - lpg the troubleshootijng chart below lists basic problems that may occur during start-up and operation. For more detailed information regarding the hydraulic and electrical systems contact your area r...
Page 26
Gb-24 ransomes highway 2130 maintenance and parts manual gb m e l b o r p s m o t p m y s s e s u a c e l b i s s o p n o i t c a n o i t c e s s n u r e n i g n e y l t c e r r o c n i s e r i f s i m e n i g n e . G n i t r o h s s g u l p k r a p s o t s d a e l n o i s n e t h g i h . 1 l a u n ...
Page 27
Gb-25 gb ransomes highway 2130 maintenance and parts manual 7 troubleshooting m e l b o r p s m o t p m y s s e s u a c e l b i s s o p n o i t c a n o i t c e s g n i d l o h t o n y r e t t a b . E g r a h c . N o t h g il y r e t t a b y r e t t a b d e d o r r o c r o e s o o l . 1 . S l a n i m...
Page 28
Gb-26 ransomes highway 2130 maintenance and parts manual gb 7 troubleshooting 7.2 lpg fault finding flow chart.
Page 29
Gb-27 gb ransomes highway 2130 maintenance and parts manual.
Page 30
Gb-28 ransomes highway 2130 maintenance and parts manual gb 8.1 hydraulic circuit 8 schematics.
Page 31
Gb-29 gb ransomes highway 2130 maintenance and parts manual 1 engine 2 transmission pump 3 transmission valve 4 front brake valve 5 lh front wheel motor 6 rh front wheel motor 7 side brake valve 8 lh rear wheel motor (4wd only) 9 rh rear wheel motor (4wd only) 10 divertor valve unit 1 11 cutting uni...
Page 32
Gb-30 ransomes highway 2130 maintenance and parts manual gb 8.2 electrical circuit engine and safety diesel 8 schematics 1 starter 2 relay 1 3 relay 2 4 heater relay 5 heater plugs 6 backlap switch 7 diff lock solenoid 8 run solenoid 9 starter back connection 10 2 wd solenoid 11 diverter solenoid 12...
Page 33
Gb-31 gb ransomes highway 2130 maintenance and parts manual 8 schematics r red g green o orange s grey b black w white k pink bg black green bo black orange nu brown blue wg white green wy white yellow p violet y yellow u blue n brown cable colour code.
Page 34
Gb-32 ransomes highway 2130 maintenance and parts manual gb 8.3 electrical circuit main lpg 8 schematics r red g green o orange s grey b black w white k pink bg black green bo black orange nu brown blue wg white green wy white yellow p violet y yellow u blue n brown cable colour code.
Page 35
Gb-33 gb ransomes highway 2130 maintenance and parts manual 8 schematics 2 relay 1 3 relay 2 6 backlap switch 7 diff lock solenoid 10 2 wd solenoid 11 diverter solenoid 12 mow solenoid 14 lamp timer 15 front lights 16 binnacle connector b 17 binnacle connector a 18 binnacle connector c 19 binnacle c...
Page 36
Gb-34 ransomes highway 2130 maintenance and parts manual gb 8.4 electrical circuit engine lpg-1 8 schematics r red g green o orange s grey b black w white k pink bg black green bo black orange nu brown blue wg white green wy white yellow p violet y yellow u blue n brown cable colour code 13 temperat...
Page 37
Gb-35 gb ransomes highway 2130 maintenance and parts manual 8 schematics 8.5 electrical circuit governor (lpg) 8.6 electrical circuit engine lpg-2 67 connector to engine harness 68 governor 69 ag relay 70 ignition relay 71 connector to tps harness 72 tps connector 73 connector to ford engine harness...
Page 38
Gb-36 ransomes highway 2130 maintenance and parts manual gb 8.7 electrical circuit instruments & controls cable colour code r red g green o orange s grey b black w white k pink p violet y yellow u blue n brown bg black green bo black orange nu brown blue wg white green wy white yellow 8 schematics.
Page 39
Gb-37 gb ransomes highway 2130 maintenance and parts manual 8 schematics 1 connector b 2 connector a 3 connector c 4 connector d 5 mow switch 6 indicator switch 7 lamp switch 8 beacon switch 9 hazard illumination 10 hazard switch 11 mow switch illumination 12 fuel gauge 13 hour meter 14 engine tenpe...
Page 40
Gb-38 ransomes highway 2130 maintenance and parts manual gb 8.8 electrical circuit fuses and relays - diesel fuse a – 20 amp (ignition) wire colours green & white. Fuse b – 20 amp (starter soleniod) wire colours white/green & white/orange fuse c – 10 amp (cab supply) wire colours white & white/purpl...
Page 41
Gb-39 gb ransomes highway 2130 maintenance and parts manual fuse s(top) – brown wire to here will have an ‘h’ identification tag, this is the circuit for the glow plug heaters (pre’heat) fuse t (middle) – brown wire to here will have an ‘a’ identification tag, this is the circuit for the alternator....
Page 42
Gb-40 ransomes highway 2130 maintenance and parts manual gb 8.9 electrical circuit fuses and relays - lpg 8 schematics fuse a – 20 amp (ignition) wire colours green & white. Fuse b – 20 amp (starter soleniod) wire colours white/green & white/orange fuse c – 10 amp (cab supply) wire colours white & w...
Page 43
Gb-41 gb ransomes highway 2130 maintenance and parts manual 8 schematics fuse t (top) – brown wire to here will have an ‘a’ identification tag, this is the circuit for the alternator. Fuse u (middle) – brown wire to here will have an ‘s’ identification tag, this is the circuit for the safety system....
Page 44
Gb-42 ransomes highway 2130 maintenance and parts manual gb notes.
Page 45
Fr-1 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 1 table des matieres 2 introduction 2.1 identification du produit ................................................................................................. 2 2.2 stockage des piÈces de rechange ..........
Page 46
Fr-2 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 2 introduction 2.2 identification du produit 2.2 stockage des piÈces de rechange afin d’assurer le fonctionnement et la rentabilité maximum de la machine, ransomes recommande de conserver les pièces de rechang...
Page 47
Fr-3 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 2 introduction 2.3 utilisation de la nomenclature numero d'article chaque pièce, identifiée sur les illustrations, est accompagnée d'un numéro. Il peut s'avérer difficile d'identifier les pièces ne possédant p...
Page 48
Fr-4 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 3 notices de securite ce symbole représente les consignes de sécurité principales à suivre. Lorsque vous voyez ce symbole, soyez conscient des risques de blessures, lisez attentivement sa consigne et prévenez ...
Page 49
Fr-5 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 3 notices de securite 3.6 avant de quitter le poste de conduite • garez la machine sur un sol plat. • arrêtez le moteur et vérifiez que les organes mobiles soient bien arrêtés. Serrez les freins et débrayez. R...
Page 50
Fr-6 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 3 notices de securite • lorsqu’il reste de l’essence dans le réservoir, n’entreposez jamais le matériel dans un bâtiment où les vapeurs risquent d’entrer en contact avec une flamme ou une étincelle nue. • s’il...
Page 51
Fr-7 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 3 notices de securite avertissement – proposition 65 la californie tient à vous informer que les fumées moteur de cette machine, ou de certains de ses composants, renferment des produits chimiques susceptibles...
Page 52
Fr-8 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 4 specifications servocommande. Conduite de 2 roues motrices avec verrouillage de différentiel. 4rm : 4 moteurs de roues individuels avec système de transmission série parallèle breveté. Sélection de blocage d...
Page 53
Fr-9 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 4 specifications 4.3 dimensions largeur de coupe : 2,14 mètre largeur de transport : 1,5 mètre hauteur hors tout : 1,56 mètre longueur hors tout : 2,68 mètre poids global de la machine : diesel : 1276 kg* 1302...
Page 54
Fr-10 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 5.1 tableau de maintenance et de graissage - machines a moteur diesel r e i l e t a n e e c n a n e t n i a m e d s e r u d é c o r p s e d t n e u q i d n i s c n a l b s t n i o p s e l s e l s u o t s r u ...
Page 55
Fr-11 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 5.2 tableau de maintenance et de graissage - machines a moteur gpl r e i l e t a n e e c n a n e t n i a m e d s e r u d é c o r p s e d t n e u q i d n i s c n a l b s t n i o p s e l s e l s u o t s r u o j...
Page 56
Fr-12 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 5.3 moteur - diesel : 50 premières heures de fonctionnement et toutes les 200 heures de service. Vidange de l’huile moteur (a) chauffez le moteur et arrêtez-le. Enlevez le bouchon de vidange (a) du fond du ca...
Page 57
Fr-13 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 5.4 machine : lubrification hebdomadaire des éléments suivants toutes les semaines ou toutes les 40 heures de fonctionnement. 1. Lubrifiez les éléments suivants à la graisse shell darina r2 : (a) pivots de br...
Page 58
Fr-14 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 5.6 machine :toutes les 800 heures de fonctionnement vidange de l’huile hydraulique 1. Enlevez le bouchon de vidange au fond du réservoir hydraulique et essuyez-le. 2. Laissez le réservoir se vider et remette...
Page 59
Fr-15 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 5 graissage et maintenance 5.8 maintenance du moteur - diesel : toutes les 100 heures de fonctionnement circuit de carburant utilisez du gasoil n° 2-d (astm d975). Reportez-vous à la notice du fabricant pour ...
Page 60
Fr-16 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 5.9 maintenance du moteur - diesel : toutes les 400 heures de fonctionnement remplacez le carburant en ligne (c) nettoyage du filtre à air eliminez toutes les poussières de l’élément avec de l’air comprimé di...
Page 61
Fr-17 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange remarque : lorsque vous lavez la machine avec des appareils à vapeur, évitez de laver les environs des paliers car les solutions de nettoyage risqueraient d’atteindre les joints d’étanchéité des paliers et de...
Page 62
Fr-18 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 5.12 entretien en fin de saison ou selon besoin changement de filtre hydraulique 1. Abaissez l’unité de coupe centrale pour améliorer l’accès. 2. Essuyez le bol filtrant (a) et le boîtier pour enlever toutes ...
Page 63
Fr-19 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange maintenance 5.12.1 entretien en fin de saison ou selon besoin changez les bougies 1. Prenez le capuchon au bout du fil, tournez-le et tirez dessus pour débrancher le fil de la bougie. 2. Après avoir desserré ...
Page 64
Fr-20 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 6.1 limiteur de vitesse les vitesses de transport et de tonte de la machine sont réglées en usine et ne doivent pas être modifiées. Ransomes jacobsen ne pourra pas être tenu responsable des baisses de perform...
Page 65
Fr-21 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 6.4 meulage la machine est équipée d’un dispositif qui permet de faire tourner les tourets en sens inverse à des fins de meulage. • le meulage est un processus, présent sur la machine, qui permet d’affûter lé...
Page 66
Fr-22 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 7.1 depistage des defauts - diesel le tableau de dépannage ci-dessous répertorie les principaux problèmes qui peuvent se produire lors du démarrage et du fonctionnement. Pour avoir des informations plus détai...
Page 67
Fr-23 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 7 depistage des defauts 7.1 depistage des defauts - gpl le tableau de dépannage ci-dessous répertorie les principaux problèmes qui peuvent se produire lors du démarrage et du fonctionnement. Pour avoir des in...
Page 68
Fr-24 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr e m è l b o r p s e m ô t p m y s s e l l e u t n e v é s e s u a c n o i t c a n o i t c e s e n r u e t o m e l s a p e n r u o t t n e m e t c e r r o c s e d a r u e t o m e l s é t a r x u a n o i s n e ...
Page 69
Fr-25 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange e m è l b o r p s e m ô t p m y s s e s u a c s e l l e u t n e v é n o i t c a n o i t c e s t n e i t e n e i r e t t a b a l . E g r a h c a l s a p e i r e t t a b e d n i o m é t . é m u ll a e i r e t t...
Page 70
Fr-26 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 7.2 organigramme de depistage des defauts gpl 7 depistage des defauts.
Page 71
Fr-27 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange.
Page 72
Fr-28 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 8.1 circuit hydraulique 8 schematique.
Page 73
Fr-29 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 8 schematique 8.1 circuit hydraulique 1 moteur 2 pompe de transmission 3 distributeur de commande 4 vanne de frein avant 5 moteur de roue avant gauche 6 moteur de roue avant droite 7 vanne de frein latérale 8...
Page 74
Fr-30 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 8.2 circuit electrique – moteur et securite 1 démarreur 2 relais 1 3 relais 2 4 relais de chauffage 5 bougies de préchauffage 6 commutateur de rodage 7 solénoïde de blocage de diff. 8 solénoïde de marche 9 co...
Page 75
Fr-31 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange r rouge g vert o orange s gris b noir w blanc k rose bg noir/vert bo noir/orange nu marron/bleu wg blanc/vert wy blanc/jaune p violet y jaune u bleu n marron code de couleur des cables 8 schematique.
Page 76
Fr-32 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 8 schematique 8.3 circuit electrique principal gpl r rouge g vert o orange s gris b noir w blanc k rose bg noir/vert bo noir/orange nu marron/bleu wg blanc/vert wy blanc/jaune p violet y jaune u bleu n marron...
Page 77
Fr-33 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 8 schematique 2 relais 1 3 relais 2 6 commutateur de rodage 7 solénoïde de blocage de diff. 10 solénoïde 2 rm 11 solénoïde de vanne de dérivation 12 solénoïde de tonte 14 temporisation d’éclairage 15 feux ava...
Page 78
Fr-34 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 8 schematique 8.4 circuit electrique moteur gpl-1 13 transmetteur de température 28 contacteur de surchauffe du moteur 29 manocontact d’huile 39 alternateur 40 fusible d’alternateur 56 fusible pour autres cir...
Page 79
Fr-35 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 8 schematique 8.5 circuit electrique regulateur (gpl) 8.6 circuit electrique moteur gpl-2 67 connecteur à faisceau moteur gpl 68 régulateur 69 relais g. A. (relais gaz auto) 70 relais d’allumage 71 connecteur...
Page 80
Fr-36 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 8.3 circuit electrique - instruments & commandes code de couleur des cables r rouge g vert o orange s gris b noir w blanc k rose p violet y jaune u bleu n marron bg noir/vert bo noir/orange nu marron/bleu wg ...
Page 81
Fr-37 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 1 connecteur b 2 connecteur a 3 connecteur c 4 connecteur d 5 commutateur de tonte 6 commutateur de d’indicateur de direction 7 commutateur de phare 8 commutateur de feu rotatif 9 eclairage des feux de détres...
Page 82
Fr-38 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr fusible a - fil 20 a (allumage) couleurs vert et blanc. Fusible b - fil 20 a (électrovalve de starter) couleurs blanc/vert et blanc/orange. Fusible c - fil 10 a (alimentation cabine) couleurs blanc et blanc/v...
Page 83
Fr-39 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange 8 schematique fusible s (arret) fil marron jusqu’à ce point, aura une étiquette d’identification ‘h’ ; c’est le circuit pour les radiateurs des bougies de préchauffage (préchauffage) fusible t (centre) fil ma...
Page 84
Fr-40 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr 8 schematique 8.5 circuit electrique - fusibles et relais - gpl fusible a - fil 20 a (allumage) couleurs vert et blanc. Fusible b - fil 20 a (électrovalve de starter) couleurs blanc/vert et blanc/orange. Fusi...
Page 85
Fr-41 fr ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fusible t (haut) – le fil marron jusqu’ici sera muni d’une étiquette d’identification ‘a’, pour le circuit de l’alternateur. Fusible u (centre) – le fil marron jusqu’ici sera muni d’une étiquette d’identifica...
Page 86
Fr-42 ransomes highway 2130 manuel de maintenance et nomenclature des pieces de rechange fr.
Page 87
Parts-1 ransomes highway 2130 maintenance and parts manual contents contents page 9 main frame .................................................................................................... 3 10.1 fuel tank - diesel .................................................................................
Page 88
Parts-2 ransomes highway 2130 maintenance and parts manual 9 main frame.
Page 89
Parts-3 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 9 main frame 60 mbf1547 asm-frame rail lh 1 61* 450242 screw, m12 x 35, hex hd 3 3 for item 60 to a 62* 450392 washer, m12 3 3 for item 61 63* 452438 nut,...
Page 90
Parts-4 ransomes highway 2130 maintenance and parts manual 8 main frame.
Page 91
Parts-5 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 8 main frame 121* 450050 bolt, m12 x 50, hex hd 8 8 for items 60, 70, 80, 90, 100, 110 &120 122* 450392 washer, m12 8 8 for items 121 123* 452438 nut, m12...
Page 92
Parts-6 ransomes highway 2130 maintenance and parts manual 9 main frame.
Page 93
Parts-7 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 9 main frame 207 mbg3368 brkt-ctr unit ram 1 208 450243 screw, m12 x 40, hex hd 3 3 for item 207 to items 60 & 90 209* 450392 washer, m12 3 3 for item 208...
Page 94
Parts-8 ransomes highway 2130 maintenance and parts manual 10.1 fuel tank - diesel.
Page 95
Parts-9 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 10.1 fuel tank - diesel 2001 mbf1596c fuel tank w/a 1 2002 a819309 diesel filler cap 1 2003 a810022 fuel sender assy 1 2004 a225001 gasket 1 2005 450528 s...
Page 96
Parts-10 ransomes highway 2130 maintenance and parts manual 10.2 fuel tank - lpg n400945 n400947 n203438 n801468 n400946 n801469 n801431 n801432 n800280 n800136 n801430 6170175 n400942 n800605 starter motor n203225 n203492 kit of parts for ford vsg 413 lpg engine fitted to the highway 2130 & parkway...
Page 97
Parts-11 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 10.2 fuel tank - lpg 4040* 4122031 lpg engine kit 1 supplied by power torque ltd, 13 n800605 • lpg - brc vapouriser 1 15* n801431 • lpg mixing screw seal...
Page 98
Parts-12 ransomes highway 2130 maintenance and parts manual 10.2 fuel tank - lpg.
Page 99
Parts-13 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 2010 n400937 vapouriser mtg. Bracket 1 2011* 450192 screw m8 x 25 hex hd 2 2012* 450390 washer, m8 5 2013* 450378 nut, m8 nyloc 3 2020 n400932 filler mtg...
Page 100
Parts-14 ransomes highway 2130 maintenance and parts manual 11 seat and frame.
Page 101
Parts-15 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 11 seat and frame 5501a 4137966 seat, grammer msg85 1 5501b 008199400 seat, grammer s85/90r 1 5502 mbg4526d seat plate w/a 1 5503 450190 screw, m8 x 16, ...
Page 102
Parts-16 ransomes highway 2130 maintenance and parts manual 12a seat grammer msg 85 seat (4137966) - suspension.
Page 103
Parts-17 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 12a seat grammer msg 85 seat (4137966) - suspension 5 008173680 cover 1 6 kit, suspension upper 1 11 kit, bellow 1 15 008173790 bolt 1 16 008173800 bushi...
Page 104
Parts-18 ransomes highway 2130 maintenance and parts manual 12b seat grammer msg 85 seat (4137966) - seat top.
Page 105
Parts-19 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 12b seat grammer msg 85 seat (4137966) - seat top 1 assy, cushion, backrest 1 2 assy, cushion, seat 1 3 screw, m5 x 25, pan hd 7 4 seat pan 1 5 backrest ...
Page 106
Parts-20 ransomes highway 2130 maintenance and parts manual 13a seat breakdown grammer (s 85 / 90r).
Page 107
Parts-21 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 13a seat breakdown s85 /90r a819940 seat assy complete 1 including suspension 1 a819945 seat cushion 1 2 a819946 back rest cushion 1 3 a819956 head rest ...
Page 108
Parts-22 ransomes highway 2130 maintenance and parts manual 13a seat breakdown grammer (s 85 / 90r).
Page 109
Parts-23 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 13a seat breakdown grammer (s 85 / 90r) 45 a819972 pin 1 46 a819973 adjusting spindle 1 47 a819974 washer 1 48 n/a plug 2 49 a819955 arm rest rh 1 50 n/a...
Page 110
Parts-24 ransomes highway 2130 maintenance and parts manual 13b seat suspension breakdown grammer ds85h.
Page 111
Parts-25 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 1 a817364 screw 6 2 a817365 stop 1 3 a817366 washer 2 4 a819964 slide with lever 1 5 a819975 slide 1 6 a817367 nut 6 7 a817368 cover 1 8 a817369 base ass...
Page 112
Parts-26 ransomes highway 2130 maintenance and parts manual 14 lift arms.
Page 113
Parts-27 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 14 lift arms 4415 2206051 wldmt-pivot pin rear 3 4416 a139382 nut-hex 1.1/4-12 nyloc 3 4417 450215 screw, m10 x 30, hex hd 3 4418 450412 s.L.Washer, m10 ...
Page 114
Parts-28 ransomes highway 2130 maintenance and parts manual 14 lift arms.
Page 115
Parts-29 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 14 lift arms 4750 lmse143 asm lift arm lh 1 4750a mbf1533 • lift arm welded asm lh 1 4750b w108003 • brg 1.5 x 1.25 x1.25 2 4750c mbf2263 • lift ram pin ...
Page 116
Parts-30 ransomes highway 2130 maintenance and parts manual 15 rear axle and steering.
Page 117
Parts-31 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 15 rear axle and steering 2201 mbf1643 2130 r-axle assy 1 2wd only 2201a* 002131020 • bush wrapped 31.8 x 39 x 30 4 2201b* w108003 • bearing 2 2202 gsf25...
Page 118
Parts-32 ransomes highway 2130 maintenance and parts manual 16 wheels.
Page 119
Parts-33 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 16 wheels 2 wheel drive machines 4329 mbg4266 wheel hub 2 4330 2208074 bearing & rubber seal 2 4331 a205902 bearing 2 4332 a159942 washer, 49/64" 2 4346 ...
Page 120
Parts-34 ransomes highway 2130 maintenance and parts manual 17.1 engine items - diesel.
Page 121
Parts-35 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 17.1 engine items - diesel 4001 a682213 fan 1 4002 a682215 fan spacer - 10mm 2 4003* 450002 bolt m6 x 35 4 4004* 450389 washer, m6 4 4007* mbf1757 jockey...
Page 122
Parts-36 ransomes highway 2130 maintenance and parts manual 17.1 engine items - diesel.
Page 123
Parts-37 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 17.1 engine items - diesel 4044 450391 washer, m10 3 4045 a129014 screw, m10x1.25x30 cap hd 3 4046 450015 bolt, m8 x 35, hex hd 4 3 for tapped holes in e...
Page 124
Parts-38 ransomes highway 2130 maintenance and parts manual 17.2 engine items - lpg.
Page 125
Parts-39 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 4003* 006911530 textron key ring 1 4004 006910690 radiator kit - kubota 1 4004.1 006911390 • radiator cap 1 4004.2 006911380 • washer* 1 4004.3 006911370...
Page 126
Parts-40 ransomes highway 2130 maintenance and parts manual 17.2 engine items - lpg.
Page 127
Parts-41 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 17.2 engine items - lpg 3 n400891 • exhaust tail pipe 1 4 n203438 • fan belt 1 4099* 4123549 'u'-clamp, 54mm 2 4089* 450412 lockwasher, m10 6 4095* 45021...
Page 128
Parts-42 ransomes highway 2130 maintenance and parts manual 17.2 engine items - lpg.
Page 129
Parts-43 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 4091* 450049 screw, m12 x 45 1 4011* 450392 washer, m12 2 4092* 450380 nut, m12 nyloc 1 4064 n4009244 heat shield 1 fixings as follows, 4072* 450192 scre...
Page 130
Parts-44 ransomes highway 2130 maintenance and parts manual 1 hydraulic tank.
Page 131
Parts-45 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 18 hydraulic tank 2101 mbf1597 hyd tank w/a 1 2102 a808963 cap-anti splash, hyd tank 1 2109 158122 tube 1 2110 450190 screw, m8 x 16, hex hd 4 2111 45039...
Page 132
Parts-46 ransomes highway 2130 maintenance and parts manual 19 hydraulic components.
Page 133
Parts-47 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 19 hydraulic components 3005 a800712 46cc servo transmission pump 1 3006 800770 cap screw 1/2-13 x 1&3/4 2 3007 a159905 washer, 33/64" 2 3008 gsf2164l 1/...
Page 134
Parts-48 ransomes highway 2130 maintenance and parts manual 19 hydraulic components.
Page 135
Parts-49 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 19 hydraulic components 3307* 450391 washer, m10 2 3308* 450412 s.L.Washer, m10 2 3309 2208047 valve-danfoss 1025 1 a801182 • handle kit 1 individual par...
Page 136
Parts-50 ransomes highway 2130 maintenance and parts manual 20 hydraulic hoses (traction circuit).
Page 137
Parts-51 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 20 hydraulic hoses (traction circuit) h 1 4124593 hose-1-7/16 90f-f x 610 lg 1 h 5 a799633 hose-1-7/16 90f-1" 90f x 795 lg 1 h10 a799634 hose-1" 45f-1-7/...
Page 138
Parts-52 ransomes highway 2130 maintenance and parts manual 21 hydraulic fittings (traction circuit).
Page 139
Parts-53 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 21 hydraulic fittings (traction circuit) f1 839820 90 elbow-1-1/16x1-7/16 ors 1 f2 158061-19 o ring 2 f5 839820 90 elbow-1-1/16x1-7/16 ors 1 f6 a254010 s...
Page 140
Parts-54 ransomes highway 2130 maintenance and parts manual 22 hydraulic hoses (lift/steer circuit).
Page 141
Parts-55 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 200 a799656 hose-11/16 45f-f x 395 lg 1 205 a799657 hose-11/16 f-90f x 395 lg 1 210 a799658 hose-11/16 f-f x 2520 lg 1 215 a799658 hose-11/16 f-f x 2520 ...
Page 142
Parts-56 ransomes highway 2130 maintenance and parts manual 23 hydraulic fittings (lift/steer circuit).
Page 143
Parts-57 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 200 w69055-01 bulkhead union 90deg elbow 11/16 1 201 w158007-01 90 deg male elbow - orfs 11/16 1 205 w69055-01 bulkhead union 90deg elbow 11/16 1 206 w15...
Page 144
Parts-58 ransomes highway 2130 maintenance and parts manual 23 hydraulic fittings (lift/steer circuit).
Page 145
Parts-59 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 200 w69055-01 bulkhead union 90deg elbow 11/16 1 201 w158007-01 90 deg male elbow - orfs 11/16 1 205 w69055-01 bulkhead union 90deg elbow 11/16 1 206 w15...
Page 146
Parts-60 ransomes highway 2130 maintenance and parts manual 24 hydraulic hoses (cutting circuit).
Page 147
Parts-61 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 24 hydraulic hoses (cutting circuit) h400 a799671 hose-11/16 f-9/16 f x 770 lg 1 h405 a799672 hose-11/16 90f-9/16 90f x 445 lg 1 h415 a799673 hose-9/16 9...
Page 148
Parts-62 ransomes highway 2130 maintenance and parts manual 24 hydraulic hoses (cutting circuit).
Page 149
Parts-63 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual h400 a799671 hose-11/16 f-9/16 f x 770 lg 1 h405 a799672 hose-11/16 90f-9/16 90f x 445 lg 1 h415 a799673 hose-9/16 90f-9/16 f x 475 lg 1 h420 a799674 hos...
Page 150
Parts-64 ransomes highway 2130 maintenance and parts manual 25 hydraulic fittings (cutting circuit).
Page 151
Parts-65 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 25 hydraulic fittings (cutting circuit) f400 a259071 90 deg fit 9/16 orfs-3/8 bsp 1 f405 a259071 90 deg fit 9/16 orfs-3/8 bsp 1 f406 a259048 swivel nut r...
Page 152
Parts-66 ransomes highway 2130 maintenance and parts manual 25 hydraulic fittings (cutting circuit).
Page 153
Parts-67 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual f400 a259071 90 deg fit 9/16 orfs-3/8 bsp 1 f405 a259071 90 deg fit 9/16 orfs-3/8 bsp 1 f406 a259048 swivel nut run tee 9/16 orfs 1 f407 a256001 fitting ...
Page 154
Parts-68 ransomes highway 2130 maintenance and parts manual 25 hydraulic fittings (cutting circuit).
Page 155
Parts-69 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual f560 a259047 swivel nut branch tee 9/16 orfs 1 f561 a251500 male connector-unf 7/16 1 f565 a252502 90 deg male elbow -unf 7/16 1 f570 w158007-05 90 deg m...
Page 156
Parts-70 ransomes highway 2130 maintenance and parts manual 26 4wd only.
Page 157
Parts-71 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 26 4wd only f1 4118826 check valve 1" orfs - 5 psi 2 f2 4118827 female 1" orfs swivel adaptor 2 f3 002590130 tee-7/8 sae x 1" orfs 2 f4 002590110 swivel ...
Page 158
Parts-72 ransomes highway 2130 maintenance and parts manual 27 electrical system.
Page 159
Parts-73 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 27 electrical system 2520 el043 elec kit 1 1* a905718 main harness 1 1.1 a824517 • diode bridge 1 situated in steering tower 1.2 a823835 • fuse carridge ...
Page 160
Parts-74 ransomes highway 2130 maintenance and parts manual 27 electrical system.
Page 161
Parts-75 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 27 electrical system 40* a905724 rear light harness 1 41* mbg4792a lamp bracket rh 1 for headlight a823179 41 mbg6728 lamp bracket rh 1 new bracket for e...
Page 162
Parts-76 ransomes highway 2130 maintenance and parts manual 27 electrical system.
Page 163
Parts-77 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 74 mbg5189 beacon handle 1 75 a299022 knob 1 76 450192 screw, m8 x 25 2 77 450390 washer, m8 1 78 450378 nut, m8 nyloc 1 78 a829526 rocker switch 1 79 a8...
Page 164
Parts-78 ransomes highway 2130 maintenance and parts manual 28 electrical/control items - lpg.
Page 165
Parts-79 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 28 electrical/control items - lpg 4034 450389 washers, m6 6 4040 4122031 lpg engine kit 1 supplied by power torque ltd 5 n203225 •gac govenor kit 1 5.1 n...
Page 166
Parts-80 ransomes highway 2130 maintenance and parts manual 29 controls.
Page 167
Parts-81 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 29 controls 5701 mbf1877 footpedal w/assy 1 5702 mbf1515 f/ped block assy lh 1 5703 mbf1516 f/ped block assy rh 1 5704 450170 scrw-hex m6 x 16 4 5705 450...
Page 168
Parts-82 ransomes highway 2130 maintenance and parts manual 29 controls.
Page 169
Parts-83 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 29 controls 5772* a119109 scrw-rnd hd #10-24 x 3/4 2 5773* a139325 nut-hex #10-24 2 5780 450195 screw, m8 x 40, hex hd 2 5781 450324 nut, m8 4 5782 45039...
Page 170
Parts-84 ransomes highway 2130 maintenance and parts manual 30 panels and covers.
Page 171
Parts-85 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 30 panels and covers 4110 mbg4402d cover-tower 1 4111 2198125 bumper 2 4112 2198084 latch-swell 1 4113* 450389 washer m6 2 4114* 38471 foam closed cell b...
Page 172
Parts-86 ransomes highway 2130 maintenance and parts manual 30 panels and covers.
Page 173
Parts-87 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 30 panels and covers 4189* a915525 acoustic pad 2 4190* 64018-20 blt-crg 1/4-20 x 1/2 16 16 for items 4193&4194 to4191&4192 4191 4120775 asm-eng cover, l...
Page 174
Parts-88 ransomes highway 2130 maintenance and parts manual 30 panels and covers.
Page 175
Parts-89 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 30 panels and covers 4272* 450377 nut, m6 nyloc 4 for item 4270 4275* 450528 screw, m5 x 16, pan hd 6 for link fuses to item 4255, fuse plate 4276* 45038...
Page 176
Parts-90 ransomes highway 2130 maintenance and parts manual 31 decals.
Page 177
Parts-91 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 31 decals idl115 decal kit 2wd 1 idl116 decal kit 4wd 1 1 009034910 • decal - instruction 1 2 009034890 • decal - bystander 1 3 009034920 • decal - hot 3...
Page 178
Parts-92 ransomes highway 2130 maintenance and parts manual 32 wheel motor front.
Page 179
Parts-93 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 32 wheel motor front 008007240 wheel motor 2 001 a808966 seal kit 1 002 a808967 seal kit 1 010 a808968 cylinder-block assy. 1 n/a • piston sub-assy.Ci.0 ...
Page 180
Parts-94 ransomes highway 2130 maintenance and parts manual 32 wheel motor front.
Page 181
Parts-95 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 081 n/a • seal support 087 n/a • key 090 n/a • shaft 096 n/a • drum brake. 097 n/a • screw. 098 n/a • brake cable. 099 n/a • snap ring. 091 a808975 set o...
Page 182
Parts-96 ransomes highway 2130 maintenance and parts manual 33 wheel motor rear.
Page 183
Parts-97 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 33 wheel motor rear a w148141-03 motor 1 me15-02-08-aaaa 1 a800664 special bolts 7 2 end cover 1 3 n/a seal ring-commutator 1 contained in seal kit a8200...
Page 184
Parts-98 ransomes highway 2130 maintenance and parts manual 34 transmission pump.
Page 185
Parts-99 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 34 transmission pump a800712 46cc servo transmission pump 1 a a800729 cylinder block kit 1 126 • piston 7 127 • slipper retainer 1 160 • cylinder block 1...
Page 186
Parts-100 ransomes highway 2130 maintenance and parts manual 35 tandempump.
Page 187
Parts-101 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 1 008007070 tandem pump 1 parker hydraulics * 008008880 • seal kit 1 for pumps with suppliers no. 332 9120 129 4124388 • seal kit 1 for pumps with suppl...
Page 188
Parts-102 ransomes highway 2130 maintenance and parts manual 36a pilot operated divertor valve - danfoss/dukes fluid power vx-947-ae 1 2 3 4 5 6 7 8 8 9 10 11 12 13.
Page 189
Parts-103 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 36a pilot operated divertor valve - danfoss/dukes a mbf2204 divertor valve 1 1 n/a body 1 2 + o ring 1 contained in seal kit a230070 3 + wiper seal 1 co...
Page 190
Parts-104 ransomes highway 2130 maintenance and parts manual 36b pilot operated divertor valve - parker.
Page 191
Parts-105 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 36b pilot operated divertor valve - parker / roquet 008012490 divertor valve 1 345 9500 196 1 n/a • housing 1 2 n/a • spool 1 3 4134154 • check valve 1 ...
Page 192
Parts-106 ransomes highway 2130 maintenance and parts manual 37 hydraulic valve - parking brake.
Page 193
Parts-107 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 37 hydraulic valve - parking brake a802834 hydraulic valve 1 1 body 1 2 knob 1 3 lever 1 4 tension pin 1 5 spring 1 6 ball 1 7 a171025 circlip 1 8 gsf35...
Page 194
Parts-108 ransomes highway 2130 maintenance and parts manual 38 lift control valve assembly danfoss / dukes fluid power.
Page 195
Parts-109 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 38 lift control valve assembly danfoss / dukes fluid power a a801068 lift valve assy. 1 1 body 1 2 spool 3 3 o ring 6 contained in seal kit a230033 4 sc...
Page 196
Parts-110 ransomes highway 2130 maintenance and parts manual 39 cutting cylinder control valve danfoss / dukes fluid power.
Page 197
Parts-111 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 39 cutting cylinder control valve danfoss / dukes fluid power a 2208047 control valve (valve-1025) 1 forward-neutral-reverse 1 a801162 seal kit 1 * a801...
Page 198
Parts-112 ransomes highway 2130 maintenance and parts manual 40 solenoid valve hydra force sv08-30
Page 199
Parts-113 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 40 solenoid valve hydra force sv08-30 a801112 solenoid valve 1 1 4144046 solenoid coil 1 with 2 pin connector 2 a801156 solenoid coil 1 without 2 pin se...
Page 200
Parts-114 ransomes highway 2130 maintenance and parts manual 41 reel drive valve hydra force.
Page 201
Parts-115 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 41 reel drive valve hydra force a 2208146 reel drive valve 1 1 178102-37 nv10-21e-0-n 1 * 178102-09 seal kit 1 2 178102-12 rv10-22h-0-n-35/30 1 * 178810...
Page 202
Parts-116 ransomes highway 2130 maintenance and parts manual 42 hydraulic steer gear.
Page 203
Parts-117 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 42 hydraulic steer gear a 2208142 hydraulic steer gear 1 1 2208142-02 bearing 1 2 2208142-03 cap 3 2208142-01 seal kit 1 4 4132556 bush 1 a 4136800 hydr...
Page 204
Parts-118 ransomes highway 2130 maintenance and parts manual 43 hydraulic steering ram.
Page 205
Parts-119 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 43 hydraulic steering ram a 008015010 hydraulic steering ram 1 * 002300820 • seal kit 1 * 002090620 • bearing (mounting) 1.
Page 206
Parts-120 ransomes highway 2130 maintenance and parts manual 44 hydraulic lift cylinder, long.
Page 207
Parts-121 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 44 hydraulic lift cylinder, long b 009027670 hydraulic lift cylinder (long) 2 c/w devol bush 1 198040-01 seal kit 1 * 009135670 devol bush 1 * 00208151 ...
Page 208
Parts-122 ransomes highway 2130 maintenance and parts manual 45 hydraulic lift cylinder, short.
Page 209
Parts-123 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 45 hydraulic lift cylinder, short a 2208152 hydraulic lift cylinder (short) 1 1 002301010 seal kit 1.
Page 210
Parts-124 ransomes highway 2130 maintenance and parts manual 46a transmission valve (parker).
Page 211
Parts-125 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 46a transmission valve (parker) 008012670 transmission valve 1 1 • body 1 42499 2 4148722 • cartridge, poppet logic 2 10 slc1-a-50 4148723 • • seal kit ...
Page 212
Parts-126 ransomes highway 2130 maintenance and parts manual 46b diff lock valve (savery).
Page 213
Parts-127 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 46b diff lock valve (savery) 1 008012060 diff lock valve 1 2 008089830 • flow divider / combiner 1 * 008089840 • • seal kit 1 3 008089850 • piloted popp...
Page 214
Parts-128 ransomes highway 2130 maintenance and parts manual i.H . P a r t n u m b e r o r d e r n u m b e r d a t e m a d e in u k c u s t o m e r n u m b e r 56 .0 0 94 .7 5 4 4 .5 0 2 1 .0 0 10 .0 0 10 7.0 0 1 0 .0 0 1 4 5 .0 0 58 .5 0 20 .0 0 67 .5 0 6 4 .0 0 1 6 5 .0 0 1 2 5 .0 0 9 a p p r o x ...
Page 215
Parts-129 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 4155556 intergrated hydraulics difflock valve 1 seal kits ct 1 4155545 flow divder / combiner cartridge 1 ct2 4155542 normally closed logic element 1 ct...
Page 216
Parts-130 ransomes highway 2130 maintenance and parts manual 47 loose parts 6 1 0 1 6 1 0 2 6 1 0 3 6 1 0 7 6 1 0 8 6 1 0 4 6 1 0 5 6 1 0 6 6 1 1 9 6 1 2 2 6 1 2 3 6 1 2 1 6 1 2 0 6 1 4 1 6 1 4 0 6 1 4 2 6 1 4 3 6 1 4 4 6 1 4 5 6 1 3 0 6 1 3 1 6 1 3 3 6 1 3 4 6 1 3 2.
Page 217
Parts-131 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 47 loose parts 6101 mbf0943 deflector wa 1 6102 mbg2028a deflector rh 1 6103 mbg2029a deflector lh 1 6104 mbc8956a bolt. 6 6105 a298383 spacer 6 6106 45...
Page 218
Parts-132 ransomes highway 2130 maintenance and parts manual 48 seals, clips and ties.
Page 219
Parts-133 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 48 seals, clips and ties all hydraulic hose assemblies, tube assemblies & hose tube assemblies have there part numbers either stamped on the sleeve, tub...
Page 220
Parts-134 ransomes highway 2130 maintenance and parts manual 49 special accessories.
Page 221
Parts-135 * not illustrated n/a not available list of parts item part no description qty remarks ransomes highway 2130 maintenance and parts manual 49 special accessories 1* lmab604 lighting kit for highway 2130 1 2* lmab640 rotating beacon kit 1 2a* el048a • beacon kit - electrical 1 2b* a905740 • ...
Page 224
Bob-cat bunton cushman jacobsen ransomes ryan e-z-go ransomes jacobsen limited west road, ransomes europark, ipswich, ip3 9tt, angleterre no. Dimmatriculation au registre du commerce : 1070731 www.Ransomesjacobsen.Com les machines ransomes jacobsen limited sont fabriquées, dans toutes nos usines, s...