Watts Premier PUR-TEK Installation, Operation And Maintenance Manual - page 20
Page 20
RECOMMENDED REPLACEMENT PARTS AND CHANGE INTERVALS:
Note: Depending on incoming feed water conditions replacement time frame may vary.
Description
Change time Frame
Cost
Sediment Pre-filter: #5m-10
6 Months
$ 3.50
Carbon Pre-filter:
#GAC-410-56/#5MCB
6 Months
$10.72
Final Carbon filter
#1m-6/#1M-10
12 Months
$ 6.75
R.O. Membrane:
#TFM-24
2 to 5 years
$64.95
Depending on water chemistry, water temperature, and water pressure Watts Premier’s R.O. Systems production and performance will vary.
Efficiency rating means the percentage of the influent water to the system that is available to the user as reverse osmosis treated water under
operating conditions that approximate typical daily usage. Recovery rating means the percentage of the influent water to the membrane portion
of the syste
storage tank is bypassed. There is an average of 4 gallons of reject water for every 1 gallon of product water produced.
REFER TO OWNER’S INSTALLATION/SERVICE MANUAL FOR FURTHER MAINTENANCE REQUIREMENTS AND WARRANTY
INFORMATION.
Phone: (623) 931-1977 Fax: (623) 931-0191 Email: wpmail@watts.com
GENERAL USE CONDITIONS:
1. S
. DO NOT use with water that
is microbiologically unsafe or unknown quality without adequate disinfection before and after the system. Systems certified for cyst reduction may be used on
disinfected water that may contain filterable cysts.
2. Operating Temperature:
Maximum: 100°F (40.5°C)
Minimum: 40° (4.4°)
3. Operating Water Pressure:
Maximum: 100 psi (7.0kg/cm2)
Minimum: 40 psi (2.8kg/cm2)
4. pH
2 to 11
5. Maximum iron present in incoming feed water supply must be less than 0.2 ppm.
6. Hardness of more than 10 grains per gallon (170 ppm) may reduce TFM membrane life expectancy.
7. Recommend TDS (Total Dissolved Solids) not to exceed 1800 ppm.
Watts Premier Inc.
1725 W. Williams Drive C-20
Phoenix, AZ 85027 USA
California Certification # 00-1452
5 SV Deluxe, CRO-TFM-5SV, Ultra 5 and Pur-Tek, Watts 25, Watts RO-4, Watts RO-5, RO-TFM-4SV, RO-TFM-5SV
System conforms to NSF Standard 58 for specific claims.
This system has been tested according to NSF/ANSI 58 for reduction of the substances listed below. The concentration of the indicated substances in water
enter
ed in NSF/ANSI 58. This
system has been tested for the treatment of water containing pentavalent arsenic (also known as As (V), As (+5), or arsenate) at concentrations of 0.30 mg/L or
less. This system reduces pentavalent arsenic, but may not remove other forms of arsenic. This system is to be used on water supplies containing a detectable free
chlorine residual at the system inlet or on water supplies that have been demonstrated to contain only pentavalent arsenic. Treatment with chloramine (combined
chlorine) is not sufficient to ensure complete conversion of trivalent arsenic to pentavalent arsenic, Please see the Arsenic Facts section of the Performance Data
Sheet for further information.
Avg. In.
Avg. Eff.
% Reduction pH
Pressure
Max Eff.
Inf. challenge
Max Allowable
(mg/L)
(mg/L)
mg/L
concentration
concentration
mg/L
mg/L
Arsenic (Pentavalent)
334.62 ug/L
5.039 ug/L
98.4%
50psi
19 ug/L
0.30±10%
0.010 mg/L
Barium Reduction
10.2
0.13
98.7%
7.24
50psi
0.27
10.0±10%
2.0
Cadmium Reduction
0.031
0.0001
99.7%
7.49
50psi
0.0009
0.03±10%
0005
Chromium (Hexavalent)
0.30
0.006
98.0%
7.24
50psi
0.013
0.03±10%
0.1
Chromium (Trivalent)
0.30
0.003
99.0%
7.24
50psi
0.008
0.03±10%
0.1
Copper Reduction
3.0
0.04
98.7%
7.64
50psi
0.06
3.0±10%
1.3
Cysts
222,077#/ml
10 #/ml
99.99%
50psi
58 minimum 50,000/mL
N/A
Fluoride Reduction
8.0
0.33
95.9%
7.49
50psi
0.47
8.0±10%
1.5
Lead Reduction
0.15
0.004
97.3%
7.49
50psi
0.008
0.15±10%
0.0107
Perchlorate
0.10
0.003
96.5%
7.39
50 psi
0.005 mg/L
0.10±10%
0.006
Radium 226/228
25pCi/L
5pCi/L
80.0%
7.24
50psi
5pCi/L
25pCiL±10%
5pCiL
Selenium
0.10
<0.001
99.0%
50psi
<0.001
0.10±10%
0.05
TDS
765
24
96.8%
7.84
50psi
39.0
750±40mg/L
187
Turbidity
81 NTU
0.15 NTU
99.8%
50psi
0.28 NTU
11±1 NTU
0.5 NTU
Recovery - 15.5%
Daily Production Rate - 9.06 GPD
Efficiency - 8.35%