1. DL manuals
  2. Webasto
  3. Automobile Accessories
  4. 300101
  5. Installation & Operation Manual

Webasto 300101 Installation & Operation Manual

Manual is about: Seat Heaters by Corbotex

Summary of 300101

  • Page 1

    Installation & operation manual kit p/n: 300101 and 300202.

  • Page 3: Contents

    Installation / operation manual seat comfort 3 contents contents.................................................................................................................................. 3 warnings: ................................................................................................

  • Page 4: Warnings:

    Installation / operation manual seat comfort 4 warnings: carbotex aftermarket seat heater systems are not designed as a “do-it-yourself“ installation products! To enhance safety and assure a high level of electrical contact of wires, simple cable/wire connectors (squeeze type splicing, etc.) cannot ...

  • Page 5: Package Contents

    Installation / operation manual seat comfort 5 notice to users of carbotex seat heating systems: the seat heater is designed to control the temperature of the lower and upper seat segment of the front seats. Proper temperature control of the vehicle seat increases the driver‘s comfort and enhances y...

  • Page 6: Disclaimer

    Installation / operation manual seat comfort 6 disclaimer the installation instructions must be followed with utmost diligence by trained and properly qualified specialists as failures to comply (or mistakes during the installation phase) may cause damage to the system, the vehicle and may potential...

  • Page 7: Introduction

    Installation / operation manual seat comfort 7 introduction carbotex after market seat heater systems are ideal comfort additions to the front seat of every vehicle. Soon after the driver and passenger have experienced the advantages of a seat heating device, the accessory will be used and valued ye...

  • Page 8: Installation Steps

    Installation / operation manual seat comfort installation steps 1 removal of seat secure the vehicle on a level and plane parking area. Remove the front seat that the seat heater is to be installed. Refer to the vehicle manufacturers recommended service procedure for proper removal of seat. 2 prepar...

  • Page 9

    Installation / operation manual seat comfort 9 5 electrical connection (rectangle switch only) mount the seat heater switch in a convenient location. Position the switch so that the marking “hi“ faces to the front of the installation. Positive power connection: connect the positive wire to an igniti...

  • Page 10

    Installation / operation manual seat comfort 10 8 electrical connection positive power connection: the connection is always to the ignition positive power. Note: make sure that the vehicle electrical system can support the seat heater power requirements. Firmly solder the red wire from the seat heat...

  • Page 11

    Installation / operation manual seat comfort 11 11 position the heating pad with the label facing down and the wire harness facing towards the rear of the vehicle seat. Adjust the pad in a way that the safety thermo protector incorporated in the heating pad is located approx. 2-5 cm forward of the b...

  • Page 12

    Installation / operation manual seat comfort 12 15 insulate the lateral "bridges", which protrude out from the previously cut area, with the supplied black insulation tape. Assure proper insulation. 16 position the heating pads on the foam seat pad. Assure that the insulated segments of the seat hea...

  • Page 13

    Installation / operation manual seat comfort 19 for safety reasons you should protect those danger spots with suitable material (i.E. Insulation tape or shrinkable hose) careful not to damage seat heater when reinstalling upholstery clamps. Run the harness from the seat heater pads in a way that it ...

  • Page 14: Technical Assistance

    Installation / operation manual seat comfort technical assistance if you require help, check our technical assistance website at http://www.Techwebasto.Com or call the technical support hotline at (800) 860-7866. 14.

  • Page 15: Limited Warranty

    Installation / operation manual seat comfort limited warranty webasto carries a 3 year or 36 ,000 miles driven limited warranty beginning from the date of installation. The warranty covers proven fabrication and materials deficiencies. Not covered in the warranty are damages resulting from: • improp...

  • Page 16

    Webasto product n.A., inc. Technical assistance hotline phone: (800) 860-7866 www.Webasto.Us www.Techwebasto.Com.