- DL manuals
- Jabiru
- Engine
- 2200
- Instruction And Maintenance Manual
Jabiru 2200 Instruction And Maintenance Manual - page 104
Jabiru Aircraft
Pty Ltd
Instruction & Maintenance Manual
Jabiru 2200 Aircraft Engine
Hydraulic Valve Lifter Models
This document is controlled while it remains on the Jabiru server. Once this no longer applies the document becomes uncontrolled.
REVISION
0
1
2
3
4
5
6 7
8
9
Dated : June 2010
Issued By: DPS
Page: 104 of 116
L:\files\Manuals_For_Products\Engine_Manuals\Transition\JEM2204-9_I&M_unsigned.docx
13 Operating Notes – Quick Reference Guide
13.1 New Engine Notes
This engine has been ground run to a specific run in program and is ready for
flight.
The engine has been INHIBITED. However if you intend to store it for any length
of time please refer to Section 5.7.3 of INSTRUCTION AND MAINTENANCE
MANUAL. Removing spark plugs and turning over will help periodically.
Before initial start add oil to engine (2.3 litres with cooler), remove one plug per
head and turn the engine over on the starter to remove excess inhibitor. Once
oil pressure is obtained replace plugs and continue start-up sequence.
Remove ALL plastic bungs on engine before starting. EXHAUST (4) CARBY (2)
OIL VENT (1) FUEL PUMP (1)
VARY your RPM when flying with a new engine.
Do not “Baby” a new engine. The purpose of breaking in an engine correctly is to
ensure a long reliable life. All moving parts need freeing up especially piston
rings to cylinder walls. This is best accomplished when the greatest B.M.E.P.
(Break Mean Effective Pressure) occurs. That is at 75% power and above. Early
running of an engine should include periods at high RPM and power settings.
Failure to operate at realistic power settings could be detrimental to engine
condition & long-term performance.
Always take off using full power
– especially when the engine is new.
Avoid heat build up
– monitor CHT and oil temps. Note that Initial temps will be
elevated due to the friction of a new engine. Careful monitoring by the pilot is
needed during this initial period to ensure long life of the engine and its
components.
CIRCUIT WORK is a good sequence for initial run in work.
i)
Abbreviate circuits initially
ii)
Step climbs and climb at shallow angles & higher airspeeds
iii)
Do not carry out glide approaches
iv)
Gradually reduce power
v)
Avoid sudden heating up and sudden cooling down
When you change oil from the “run in” type to the “normal” oil at or around 25
hrs, replace oil filter.
Summary of 2200
Page 1
Instruction and maintenance manual for jabiru 2200 aircraft engine document no. Jem2204-9 this manual has been prepared as a guide to correctly operate, maintain and service the jabiru 2200 engine. It is the owner's responsibility to regularly check the jabiru web site at www.Jabiru.Net.Au for appli...
Page 2: 1 Table of Contents
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 3
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 4
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 5
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 6
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 7: 2 Description
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 8
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 9
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 10
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 11: 3 Specifications
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 12
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 13
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 14
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 15
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 16
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 17
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 18: 4 Operating Instructions
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 19
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 20
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 21
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 22
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 23
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 24
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 25
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 26
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 27
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 28: 6 Maintenance
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 29
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 30
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 31
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 32
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 33
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 34
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 35
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 36
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 37: 7 Service & Repair
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 38
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 39
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 40
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 41
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 42
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 43
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 44
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 45
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 46
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 47
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 48
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 49
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 50
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 51
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 52
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 53
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 54
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 55
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 56
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 57
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 58
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 59
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 60
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 61
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 62
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 63
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 64
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 65
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 66
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 67
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 68
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 69
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 70
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 71
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 72
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 73
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 74
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 75
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 76
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 77
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 78
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 79
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 80
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 81: 9 Service Documentation
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 82
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 83
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 84
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 85
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 86
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 87
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 88
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 89
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 90
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 91
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 92
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 93
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 94
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 95
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 96
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 97
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 98: 11 Table Of Lubricants
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 99
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 100
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 101
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 102
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 103
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 104
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 105
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 106
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 107
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 108: 14 Trouble Shooting
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 109
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 110
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 111
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 112
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 113
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 114
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 115
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 116
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...