- DL manuals
- Jabiru
- Engine
- 2200
- Instruction And Maintenance Manual
Jabiru 2200 Instruction And Maintenance Manual - page 106
Jabiru Aircraft
Pty Ltd
Instruction & Maintenance Manual
Jabiru 2200 Aircraft Engine
Hydraulic Valve Lifter Models
This document is controlled while it remains on the Jabiru server. Once this no longer applies the document becomes uncontrolled.
REVISION
0
1
2
3
4
5
6 7
8
9
Dated : June 2010
Issued By: DPS
Page: 106 of 116
L:\files\Manuals_For_Products\Engine_Manuals\Transition\JEM2204-9_I&M_unsigned.docx
13.2.2
Oil
Use a non-compounded AVIATION oil:-
Aero Shell 100
Mobil Red Band (EXXON Aviation Oil 100)
BP Aviation Oil 100
Use for 20-25 hours, then drain and replace with a compounded AVIATION oil:-
Aero Shell W100
Aero Shell 15W50 (for cooler climates)
Mobil Aero 100 (SAE 50) (EXXON Aero Elite 100)
BP Aero Oil D100/BP Multigrade Aero Oil D SAE 20 W 50
Aero Shell W 100 Plus
The normal running oils are detergent and ashless dispersant types. See
MAINTENANCE SECTION 5.3
Oil capacity:
The new engine will hold 2.3 litres with an oil cooler.
On subsequent oil changes the engine will hold approx 2.2 litres.
Do not use any type of automotive oil. Aviation oils have been blended specifically
for the difficult operating conditions found in an air cooled aero engine operation and
using automotive will be extremely detrimental to its operation.
When you change oil from the “run in” type to the “normal” oil at or around 25 hrs
replace oil filter. You may want to cut the filter open for inspection. It is usual in Jabiru
engines to find a small amount of aluminium but definitely no metal. If bearing metal is
present contact the Jabiru Service Department.
13.2.3
Engine Cooling
Avoid prolonged ground running at elevated RPM. Engine can be over heated during
ground operations
– remember air ducts are designed for in flight cooling. Ground
running at high power settings for more than a few minutes requires the use of special,
oversize air ducts and oil cooler.
Do not apply full power until CHT has reached at least 100°C (212°F)
ALWAYS TAKE OFF AT FULL POWER
– especially when the engine is new.
For the first few take offs climb at a higher airspeed than normal to assist engine
cooling. Reduce power at cross wind leg and shallow climb (lower nose).
Avoid high nose altitude continual climbs. The higher the climb out speed the better for
engine cooling. No low speed high nose altitude climb outs.
RETORQUE heads on annual inspection.
Summary of 2200
Page 1
Instruction and maintenance manual for jabiru 2200 aircraft engine document no. Jem2204-9 this manual has been prepared as a guide to correctly operate, maintain and service the jabiru 2200 engine. It is the owner's responsibility to regularly check the jabiru web site at www.Jabiru.Net.Au for appli...
Page 2: 1 Table of Contents
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 3
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 4
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 5
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 6
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 7: 2 Description
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 8
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 9
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 10
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 11: 3 Specifications
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 12
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 13
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 14
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 15
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 16
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 17
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 18: 4 Operating Instructions
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 19
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 20
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 21
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 22
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 23
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 24
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 25
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 26
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 27
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 28: 6 Maintenance
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 29
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 30
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 31
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 32
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 33
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 34
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 35
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 36
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 37: 7 Service & Repair
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 38
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 39
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 40
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 41
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 42
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 43
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 44
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 45
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 46
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 47
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 48
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 49
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 50
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 51
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 52
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 53
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 54
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 55
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 56
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 57
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 58
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 59
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 60
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 61
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 62
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 63
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 64
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 65
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 66
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 67
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 68
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 69
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 70
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 71
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 72
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 73
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 74
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 75
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 76
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 77
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 78
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 79
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 80
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 81: 9 Service Documentation
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 82
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 83
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 84
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 85
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 86
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 87
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 88
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 89
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 90
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 91
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 92
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 93
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 94
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 95
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 96
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 97
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 98: 11 Table Of Lubricants
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 99
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 100
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 101
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 102
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 103
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 104
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 105
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 106
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 107
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 108: 14 Trouble Shooting
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 109
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 110
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 111
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 112
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 113
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 114
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 115
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 116
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...