- DL manuals
- Jabiru
- Engine
- 2200
- Instruction And Maintenance Manual
Jabiru 2200 Instruction And Maintenance Manual - page 64
Jabiru Aircraft
Pty Ltd
Instruction & Maintenance Manual
Jabiru 2200 Aircraft Engine
Hydraulic Valve Lifter Models
This document is controlled while it remains on the Jabiru server. Once this no longer applies the document becomes uncontrolled.
REVISION
0
1
2
3
4
5
6 7
8
9
Dated : June 2010
Issued By: DPS
Page: 64 of 116
L:\files\Manuals_For_Products\Engine_Manuals\Transition\JEM2204-9_I&M_unsigned.docx
Idling should always be with the engine at operating temperature. First the mixture control
screw (7) is turned fully clockwise and then backed off by the number of turns specified for
the particular engine. Turning in clockwise direction results in a leaner mixture and turning
in anti-clockwise direction in a richer mixture.
The idling setting quoted serves as a guide only. The optimum will generally differ slightly.
First select the desired idling speed by using the idling stop screw (34). When
subsequently adjusting the mixture control screw - starting from the basic setting - a speed
drop will be noticed in both directions. The optimum setting will generally be found half-
way between the two settings at which this speed drop was noticed.
To facilitate the idling setting on engines having several carburettors where it is important
that they are evenly adjusted, it is possible to connect a pressure gauge (in the simplest
case a "U-tube pressure gauge") to a nipple below the throttle valve shaft bearing point
which is normally closed off by screw (39). To select the idling speed, the idling screw
(34) is in this case adjusted until the same vacuum is indicated for all carburettors. By
slightly opening the throttle valve via a turning handle or the accelerator it is also possible
to adjust Bowden cables or linkages evenly by making this vacuum comparison.
STARTING CARBURETTOR
BING constant depression carburettor is provided with a rotary valve starting carburettor
as an aid for staring a cold engine using a Bowden cable. A disc (47) resting against the
carburettor housing is turned via a shaft in the starting carburettor housing (48) so that the
starting carburettor chamber into which air enters from the air filter side of the carburettor
is connected to the engine side of the carburettor via a duct. The airport in the disc (47) is
shaped in such a way that depending on the disc position, more or less air is drawn in. At
the same time the disc opens the fuel system of the starting carburettor via bores matched
to the disc position. The fuel flows from the float chamber through the starting jet into the
vented starting chamber also contained in the float chamber (44) and from there through a
riser where it is pre-mixed with air via transverse bores, into the starting carburettor.
There it forms a particularly rich mixture with the air drawn in, and this mixture bypasses
the main carburettor to flow into the intake manifold of the engine direct. During starting
the throttle valve has to be closed to make sufficient vacuum available for the
starting carburettor. When the engine is at a standstill and also during normal operation
the fuel level in the float chamber compartment incorporating the riser will be the same as
in the rest of the float chamber. When starting with opened-up starting carburettor, the
fuel will initially be drawn in from this compartment which forms a very rich mixture. The
fuel supplied subsequently will only be the amount allowed through by the starting jet.
This ensures that, once the engine has started, it is not supplied with an excessively rich
mixture and stalled. The starting carburettor is therefore matched to any given engine by
modifying the starting jet and matching the space behind it.
The starting carburettor is secured to the carburettor housing by four screws (51) and
protected against ingress of dirt and water by the seal (50) between the two. The starting
shaft is also sealed against the starting carburettor housing by a rubber ring (49).
Summary of 2200
Page 1
Instruction and maintenance manual for jabiru 2200 aircraft engine document no. Jem2204-9 this manual has been prepared as a guide to correctly operate, maintain and service the jabiru 2200 engine. It is the owner's responsibility to regularly check the jabiru web site at www.Jabiru.Net.Au for appli...
Page 2: 1 Table of Contents
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 3
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 4
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 5
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 6
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 7: 2 Description
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 8
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 9
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 10
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 11: 3 Specifications
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 12
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 13
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 14
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 15
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 16
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 17
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 18: 4 Operating Instructions
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 19
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 20
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 21
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 22
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 23
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 24
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 25
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 26
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 27
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 28: 6 Maintenance
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 29
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 30
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 31
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 32
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 33
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 34
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 35
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 36
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 37: 7 Service & Repair
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 38
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 39
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 40
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 41
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 42
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 43
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 44
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 45
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 46
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 47
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 48
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 49
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 50
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 51
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 52
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 53
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 54
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 55
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 56
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 57
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 58
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 59
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 60
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 61
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 62
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 63
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 64
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 65
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 66
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 67
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 68
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 69
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 70
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 71
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 72
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 73
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 74
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 75
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 76
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 77
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 78
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 79
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 80
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 81: 9 Service Documentation
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 82
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 83
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 84
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 85
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 86
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 87
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 88
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 89
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 90
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 91
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 92
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 93
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 94
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 95
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 96
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 97
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 98: 11 Table Of Lubricants
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 99
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 100
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 101
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 102
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 103
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 104
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 105
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 106
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 107
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 108: 14 Trouble Shooting
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 109
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 110
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 111
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 112
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 113
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 114
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 115
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 116
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...