- DL manuals
- Jabiru
- Engine
- 2200
- Instruction And Maintenance Manual
Jabiru 2200 Instruction And Maintenance Manual - page 70
Jabiru Aircraft
Pty Ltd
Instruction & Maintenance Manual
Jabiru 2200 Aircraft Engine
Hydraulic Valve Lifter Models
This document is controlled while it remains on the Jabiru server. Once this no longer applies the document becomes uncontrolled.
REVISION
0
1
2
3
4
5
6 7
8
9
Dated : June 2010
Issued By: DPS
Page: 70 of 116
L:\files\Manuals_For_Products\Engine_Manuals\Transition\JEM2204-9_I&M_unsigned.docx
Head Fitting
H9
1. Insure
* All O Rings are place and greased
* Have all head bolts
* Push rod tubes
* Push Rods
* Loctite 515
* Loctite 243
2. Fit heads by hand.
3. Oil hydraulic lifters liberally & place into sockets in case.
4. Fit O-rings to case & push rod adaptors and install adaptors to case.
5. Push the push rod tube through the head and all the way home. Fit circlips.
Note: Make sure outside of tubes are smooth or it will damage the O-Rings
6. Oil Push rods and fit.
Note: Make sure ball end of push rod is in the socket of the lifter. It also helps if
the lifter is on the base circle of the lobe. Lifters should be filled with oil before
fitting.
7. Put loctite 243 on rocker shaft cap screw and torque to 8 ft lbs after fitting
rockers.
8. Torque head bolts to 16 nm then 32 nm (12 ft lbs then 24 ft lbs).
Sump and Induction
H10 1. Fit sump using loctite 515 on faces and loctite 243 on threads.
Note: Because the engine mount plate goes on the sump and crankcase it is
important to make sure the sump is level with the rear crank case face. There are
two additional cap screws between the backing plate and the sump, covered by the
gear case. These screws have been removed from later engines.
2. Fit 3 & 4 induction pipe to heads then 1 & 2
3. Fit lower pipes and hoses
Gear Case
H11 1. Insure
* Gear case is fitted up
* Backing plate is ready
* All bolts are ready
* Loctite 515
* Loctite 242
* Loctite 620
2. Turn engine around until it is 25° B.T.D.C. No. 1 compression
3. Put loctite 515 on crankcase. Fit engine mount plate. Make sure 4 inside cap
screws are in. Use loctite 242 on all cap screws.
4. Put loctite on gear case & point rotors to No. 1 Position.
Note: It is recommended that rotors are attached with small amount of silastic or 5
minute araldite/flox mix. This will prevent them from loosening. This still allows
rotors to be removed when necessary.
Summary of 2200
Page 1
Instruction and maintenance manual for jabiru 2200 aircraft engine document no. Jem2204-9 this manual has been prepared as a guide to correctly operate, maintain and service the jabiru 2200 engine. It is the owner's responsibility to regularly check the jabiru web site at www.Jabiru.Net.Au for appli...
Page 2: 1 Table of Contents
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 3
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 4
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 5
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 6
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 7: 2 Description
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 8
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 9
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 10
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 11: 3 Specifications
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 12
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 13
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 14
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 15
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 16
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 17
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 18: 4 Operating Instructions
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 19
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 20
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 21
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 22
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 23
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 24
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 25
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 26
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 27
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 28: 6 Maintenance
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 29
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 30
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 31
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 32
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 33
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 34
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 35
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 36
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 37: 7 Service & Repair
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 38
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 39
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 40
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 41
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 42
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 43
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 44
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 45
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 46
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 47
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 48
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 49
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 50
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 51
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 52
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 53
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 54
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 55
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 56
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 57
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 58
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 59
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 60
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 61
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 62
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 63
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 64
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 65
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 66
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 67
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 68
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 69
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 70
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 71
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 72
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 73
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 74
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 75
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 76
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 77
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 78
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 79
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 80
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 81: 9 Service Documentation
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 82
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 83
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 84
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 85
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 86
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 87
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 88
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 89
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 90
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 91
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 92
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 93
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 94
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 95
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 96
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 97
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 98: 11 Table Of Lubricants
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 99
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 100
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 101
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 102
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 103
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 104
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 105
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 106
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 107
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 108: 14 Trouble Shooting
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 109
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 110
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 111
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 112
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 113
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 114
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 115
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 116
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...