- DL manuals
- Jabiru
- Engine
- 2200
- Instruction And Maintenance Manual
Jabiru 2200 Instruction And Maintenance Manual - page 62
Jabiru Aircraft
Pty Ltd
Instruction & Maintenance Manual
Jabiru 2200 Aircraft Engine
Hydraulic Valve Lifter Models
This document is controlled while it remains on the Jabiru server. Once this no longer applies the document becomes uncontrolled.
REVISION
0
1
2
3
4
5
6 7
8
9
Dated : June 2010
Issued By: DPS
Page: 62 of 116
L:\files\Manuals_For_Products\Engine_Manuals\Transition\JEM2204-9_I&M_unsigned.docx
The float chamber (44) is secured to the carburettor housing by a spring yoke (45). A seal
(46) is provided between float chamber and carburettor housing. The space above the
fuel level is connected to atmosphere by two ducts. When these ducts are blocked, an air
cushion forms above the fuel. The fuel will not lift the float sufficiently to close the needle
valve and the carburettor overflows.
The float chamber (44) incorporates an overflow pipe to allow fuel to drain off if the
specified level in the float chamber is exceeded substantially due to a leaking needle
valve.
MAIN REGULATING SYSTEM WITH PRESSURE REGULATOR
The amount of mixture drawn in by the engine and thus its performance is determined by
the cross-sectional area in the choke tube which is opened by the throttle valve (23). The
throttle valve is secured to the valve shaft (24) by two screws (25). The end projecting
from the carburettor housing carries the throttle levers (27) + (28) which are secured by
the nut (3) and washer (29) to which the Bowden cable operating the throttle shaft is
attached. The sealing ring (26) provides the seal between valve shaft and housing. The
retaining arm (31) attached to the carburettor housing by means of screws (32) and
washers (33) engages the notch in the valve shaft and thus prevents it from moving in
axial direction. The return spring (35) whose action opposes the Bowden cable is
attached between a bent-over tab at the lower end of the retaining arm and the throttle
lever (28). If the throttle valve (23) is opened while the engine is running, the increased air
flow in the choke tube results in a vacuum building up at the outlet of the needle jet (3)
which draws fuel from the float chamber through the jet system. At low speeds and in
particular in the case of four-stroke engines, this vacuum is not sufficient for an adequate
fuel supply; it must therefore be increased artificially by using a pressure regulator. For
this purpose the BING constant depression carburettor type 94 is provided with a plunger
(13) operating in conjunction with a diaphragm (16); which reduces the cross-sectional
area or the needle jet outlet by virtue of its own weight or, in some applications with the
additional pressure from a spring (22), and thus increases air velocity and vacuum at this
point.
The plunger (13) is located centrally in the cover (20) which is secured to the carburettor
housing by screws (21). The diaphragm (16) is connected to the plunger (13) by a
retaining ring (17) and four screws (18) and washers (19) each. The vacuum in the choke
tube acts on the top of the diaphragm and the plunger via a bore (U) in the plunger (13)
and attempts to lift the plunger against its own weight and spring (22). The considerably
lower vacuum between air filter and carburettor is applied to the underside of the
diaphragm via duct (V) as a reference pressure.
If the throttle valve (23) is opened when the plunger (13) is closed, then a vacuum will
build up in the small cross-section at the bottom of the plunger (13) which is sufficient to
provide a supply of fuel. The weight of the plunger (13) and the force of the spring (22)
are matched in such a way that this vacuum will be maintained with increasing speed until
the plunger has fully opened the carburettor cross-section. From this point onwards the
carburettor acts as a throttle valve carburettor with fixed choke tube. The vacuum
increases with increasing speed.
Summary of 2200
Page 1
Instruction and maintenance manual for jabiru 2200 aircraft engine document no. Jem2204-9 this manual has been prepared as a guide to correctly operate, maintain and service the jabiru 2200 engine. It is the owner's responsibility to regularly check the jabiru web site at www.Jabiru.Net.Au for appli...
Page 2: 1 Table of Contents
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 3
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 4
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 5
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 6
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 7: 2 Description
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 8
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 9
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 10
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 11: 3 Specifications
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 12
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 13
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 14
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 15
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 16
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 17
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 18: 4 Operating Instructions
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 19
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 20
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 21
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 22
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 23
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 24
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 25
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 26
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 27
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 28: 6 Maintenance
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 29
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 30
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 31
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 32
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 33
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 34
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 35
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 36
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 37: 7 Service & Repair
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 38
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 39
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 40
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 41
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 42
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 43
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 44
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 45
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 46
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 47
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 48
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 49
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 50
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 51
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 52
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 53
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 54
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 55
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 56
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 57
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 58
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 59
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 60
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 61
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 62
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 63
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 64
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 65
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 66
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 67
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 68
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 69
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 70
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 71
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 72
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 73
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 74
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 75
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 76
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 77
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 78
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 79
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 80
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 81: 9 Service Documentation
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 82
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 83
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 84
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 85
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 86
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 87
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 88
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 89
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 90
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 91
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 92
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 93
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 94
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 95
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 96
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 97
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 98: 11 Table Of Lubricants
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 99
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 100
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 101
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 102
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 103
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 104
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 105
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 106
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 107
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 108: 14 Trouble Shooting
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 109
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 110
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 111
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 112
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 113
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 114
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 115
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...
Page 116
Jabiru aircraft pty ltd instruction & maintenance manual jabiru 2200 aircraft engine hydraulic valve lifter models this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Revision 0 1 2 3 4 5 6 7 8 9 dated : june 2010 issued b...