Kalamazoo K1000HB Use And Care Manual - page 41

1.800.868.1699

37

A

A

B

C

To Adjust the Ignition Burner Air Shutter: 

The ignition burner air shutter (see Figure 25:A page 36) is accessed within the base cabinet of the grill at the 

left-hand side or by removing the control panel (see previous section on adjusting the main burner air shutters 

for instructions on removing the control panel).Open the cabinet door and look inside up below the control 

panel to locate the ignition burner air shutter. The air shutter is factory adjusted and should rarely need any 

further adjustment. If you are experiencing yellow or orange flames rather than blue, it is possible the insect 

screen over the air shutter has become clogged. Check the screen before adjusting the opening.

Loosen the screw that secured the air shutter (see Figure 27:B). Use care not to remove the screw by loosening 

too far. Adjust the air shutter until the flames burn blue, are stable, and do not lift off the burner. Secure the air 

shutter in position by re-tightening the screw. 

To Clean the Ignition  Burner Air Shutter: 

Gently brush away debris from the screen (see Figure 27:C) using an old toothbrush.

Rotisserie Burners and Cooktop Burners Do Not Require Any Air Mixture 

Adjustment

FIGURE 27