Quadra-Fire MTV-E2-CSB Installation Manual - page 2
2
7080-131H
July 1, 2015
MT VERNON E2
TABLE OF CONTENTS
Safety Alert Key:
• DANGER!Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION!Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the appliance or to property.
Quadra-Fire is a registered trademark of Hearth & Home Technologies.
1
Important Safety Information ............ 3
A. Appliance Certifi cation ......................................................3
B. BTU & Effi ciency Specifi cations........................................3
C. Glass Specifi cations .........................................................3
D. Electrical Rating................................................................3
E. Mobile Home Approved .................................................... 3
F. Non-Combustible Materials ................................................3
G. Combustible Materials .......................................................3
2
Getting Started ................................... 4
A. Design, Installation & Location Considerations ..........................4
B. Thermostat Location ..........................................................5
C. Tools And Supplies Needed ..............................................5
D. Inspect Appliance and Components .................................5
E. Install Checklist ..................................................................6
3
Dimensions and Clearances ............. 7
A. Appliance Dimensions ......................................................7
B. Clearances to Combustibles (US & Canada) ....................8
C. Hearth Pad Requirements (US & Canada)........................8
D. Alcove ..............................................................................9
4
Vent Information ............................... 10
A. Venting Termination Minimum Requirements ...................10
B. Avoiding Smoke and Odors ...............................................11
C. Negative Pressure
.....................................................12
D. Draft .............................................................................12
E. Chimney and Exhaust Connection ..................................12
F. Equivalent Feet of Pipe ....................................................13
G. Pipe Selection Chart ........................................................13
5
Venting Systems .............................. 14
A. Through The Wall .............................................................14
B. Vertical into Existing Class A Chimney .............................15
C. Through The Wall & Vertical - Exterior ..............................15
D. Vertical - Interior - Typical Installation ................................15
E. Masonry ............................................................................16
F. Alternate Masonry .............................................................16
6
Appliance Set-Up ............................. 17
A. Leg Leveling System .......................................................17
B. Outside Air Kit Instructions ................................................17
C. Top Vent Adapter Installation ............................................18
D. Rear Vent & Rear Vent to Top Vent Adapter Installation ...18
E. Optional Log Set Placement Instructions ..........................19
F. Thermostat Installation .....................................................20
G. Power Cord .......................................................................21
H. Trim Adjustment .................................................................22
7
Mobile Home Installation ................. 23
8
Accessory List ................................. 24