1. DL manuals
  2. U-Line
  3. Refrigerator
  4. CLRCO2175
  5. Installation Manual

U-Line CLRCO2175 Installation Manual

Manual is about: ÉCHELON MODELS ORIGINS MODELS

Summary of CLRCO2175

  • Page 1

    Www.U-lineservice.Com phone (414) 354-0300 • fax (414) 354-7905 service & parts tech lines phone (800) 779-2547 • fax (414) 354-5696 onlineservice@u-line.Com ©2006 u-line corporation 08/2006 clrco2175 combo ® — clear ice maker/refrigerator installation guide.

  • Page 2

    Www.U-lineservice.Com 2 08/2006 clrco2175 combo®— clear ice maker/refrigerator contents exterior cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 cut-out dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 product dimensions . . . . . . . . . . . . . . . . . . . ...

  • Page 3

    08/2006 3 www.U-lineservice.Com clrco2175 combo®— clear ice maker/refrigerator general precautions use this appliance for its intended purpose only and follow these general precautions along with those listed throughout this guide: warning shock hazard — electrical grounding required. • keep the uni...

  • Page 4

    Www.U-lineservice.Com 4 08/2006 clrco2175 combo®— clear ice maker/refrigerator after all the protective coating has been removed from the unit/door, clean all stainless steel surfaces with claire stainless steel polish and cleaner or comparable product or a mild detergent and warm water solution and...

  • Page 5

    08/2006 5 www.U-lineservice.Com clrco2175 combo®— clear ice maker/refrigerator product dimensions please note that the unit has adjustable feet that can add one additional inch to height during leveling or to match adjacent cabinets (see figure 44 on page 17). Door swing/clearances information black...

  • Page 6

    Www.U-lineservice.Com 6 08/2006 clrco2175 combo®— clear ice maker/refrigerator 4. Remove the two door closer inserts from the existing bottom hinge and install as shown on the new bottom hinge (see figure 8). 5. Remove existing bottom hinge (3 screws) and remount on opposite side top. Remove hinge s...

  • Page 7

    08/2006 7 www.U-lineservice.Com clrco2175 combo®— clear ice maker/refrigerator side-by-side installation instructions for a complete refreshment center, install your clrco2175 clear ice maker/refrigerator beside a u-line drawer or wine captain model (see figure 11 for typical cut-out). Note that eac...

  • Page 8

    Www.U-lineservice.Com 8 08/2006 clrco2175 combo®— clear ice maker/refrigerator 2. Pull door gasket out of groove (top edge of door only). Start in the middle and pull outward, moving toward the edge (see figure 13). This may take some force. 3. Remove two outside screws holding door handle. Slightly...

  • Page 9

    08/2006 9 www.U-lineservice.Com clrco2175 combo®— clear ice maker/refrigerator 2. Create a relief (figure 15) for pivot plate by cutting notch in top corner of overlay panel. Refer to figure 16 for exact specifications. Route notch in top corner of overlay panel as shown (see top and side views). To...

  • Page 10

    Www.U-lineservice.Com 10 08/2006 clrco2175 combo®— clear ice maker/refrigerator 3. Attach the door panel to the overlay panel using #10 x 5/8" wood screws and nylon spacers. The nylon spacers fit between the overlay panel and the door panel as shown in figure 21. The spacers allow the original door ...

  • Page 11

    08/2006 11 www.U-lineservice.Com clrco2175 combo®— clear ice maker/refrigerator 4. Attach top pivot plate to door handle, on side where hinges will be. Use the two #8-32 x 1/2" flat head phillips screws (black) supplied with kit (see figure 24). 5. Starting at the corners and working toward the cent...

  • Page 12

    Www.U-lineservice.Com 12 08/2006 clrco2175 combo®— clear ice maker/refrigerator checking door alignment the unit’s door is aligned at the factory before shipment. However, its alignment could have been disturbed during shipment or during door panel installation. Important properly aligned, the door ...

  • Page 13

    08/2006 13 www.U-lineservice.Com clrco2175 combo®— clear ice maker/refrigerator caution plumbing installation must observe all state and local codes. All water and drain connections must be made by a licensed/qualified plumbing contractor. Failure to follow recommendations and instructions may resul...

  • Page 14

    Www.U-lineservice.Com 14 08/2006 clrco2175 combo®— clear ice maker/refrigerator important before installing your u-line clrco2175 with factory- installed u-line p60 pump, it is extremely important to check and test all hose connections at the drain pump. There is a possibility that hose connections ...

  • Page 15

    08/2006 15 www.U-lineservice.Com clrco2175 combo®— clear ice maker/refrigerator 5. Place a suitable container beneath the pump’s discharge tube. (the bucket must be able to hold a minimum of one gallon.) 6. Plug the ice maker power cord into a properly grounded, polarized electrical outlet. 7. Verif...

  • Page 16

    Www.U-lineservice.Com 16 08/2006 clrco2175 combo®— clear ice maker/refrigerator 3. Carefully bend the water supply line into position and connect the line to the solenoid valve (see figure 40). Avoid kinking the water supply line. Important normal operation creates some vibration. A water supply lin...

  • Page 17

    08/2006 17 www.U-lineservice.Com clrco2175 combo®— clear ice maker/refrigerator leveling information important it is extremely important that the unit is level. If it is not level, the ice mold will not fill evenly. A unit that is not level can cause a reduction in ice rate, uneven sized cubes or wa...

  • Page 18

    Www.U-lineservice.Com 18 08/2006 clrco2175 combo®— clear ice maker/refrigerator installation of the clrco2175 1. Open the water supply valve in the main water source. 2. Plug in the power cord. 3. Open the door and press the power icon (see figure 47, 1) on the display until off is displayed.. Note:...

  • Page 19

    08/2006 19 www.U-lineservice.Com clrco2175 combo®— clear ice maker/refrigerator initial start-up once installation and leveling is complete, the unit is ready for initial start-up and operation. The display panel is located inside the unit, on the top of the refrigerator side(see figure 47, 1). The ...

  • Page 20

    Www.U-lineservice.Com 20 08/2006 clrco2175 combo®— clear ice maker/refrigerator start-up troubleshooting problem q: unit does not appear to turn on when power icon is pressed. Solution a: remember that the compressor will not operate until the water has been filling for about 3 minutes. Make sure un...

  • Page 21

    ?2006 u-line corporation publication no. 30141e 08/2006 rev. B u-line corporation, located in milwaukee, wi, is a family operated manufacturer of built-in undercounter icemakers, combo ® icemaker/refrigerators, wine captain ® wine storage units, refrigerators, refrigerated drawers and refrigerator/f...