1. DL manuals
  2. Vanner
  3. Inverter
  4. SRC12-1200L
  5. Owner's Manual

Vanner SRC12-1200L Owner's Manual

Manual is about: Inverter/Charger

Summary of SRC12-1200L

  • Page 1

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 1 i n c o r p o r a t e d src12-1200l/s inverter/charger model - src12-1200l/s owner's manual - d913482 release 1.0

  • Page 2: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 2 i n c o r p o r a t e d 12 volt battery inverter/charger oem alternator oem battery common oem ground at starter or engine block fuse block within 18" of battery typical inverter installation.

  • Page 3: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 3 i n c o r p o r a t e d table of contents 1 introduction..................................................................................................................................4 2 specifications ....................

  • Page 4: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 4 i n c o r p o r a t e d 11.2 troubleshooting procedures..................................................................................................... 20 12 appendices ...................................................

  • Page 5: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 5 i n c o r p o r a t e d 2 specifications specifications model src12-1200l/s continuous output power rating 1,200 watts @ 25°c (77°f) ambient 1,100 watts @ 40°c (104°f) ambient output surge capacity 2,600 watts dc input vol...

  • Page 6: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 6 i n c o r p o r a t e d 3 standard features 3.1.1 true rms regulated 120 volt ±10% ac 60 hz quasi-sine wave output 3.1.2 output short circuit / overload protection through electronic sensing 3.1.3 input and output circuit ...

  • Page 7: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 7 i n c o r p o r a t e d 1 to the off position can turn off the load demand feature. This will cause the inverter to remain fully on; producing 120 volts ac whenever the inverter switch is on regardless of ac load. 4.3 auto...

  • Page 8: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 8 i n c o r p o r a t e d caution do not cover or obstruct ventilation openings. Do not mount in zero-clearance compartments. Overheating may result which may diminish system capacity. Notice the output of this device in not...

  • Page 9: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 9 i n c o r p o r a t e d 5 never smoke or allow a spark of flame in the vicinity of batteries. Gases produced by batteries are explosive. 6 care should be taken when working with metal tools around batteries. Potentials for...

  • Page 10: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 10 i n c o r p o r a t e d 7 component identification on off 5 inverter control terminal inv/chg steady=inverter on battery low over temp over load float bulk/ absorption on off/reset remote or ifm1 charger inverter blink=st...

  • Page 11: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 11 i n c o r p o r a t e d 1 – on/off/reset push button the on/off switch is a pushbutton switch used to turn the inverter function on/off and is used as a reset switch. (note: the charger function is controlled on/off by th...

  • Page 12: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 12 i n c o r p o r a t e d charger indicator lights 6 – bulk/absorption indicator light (see ‘battery charger theory of operation’ for battery charging performance details.) light action description blinking yellow the unit ...

  • Page 13: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 13 i n c o r p o r a t e d additional features 15 – 120v, 60hz @ 15a max. Ac output utilizing the phillips & temro connectors all output will be protected for ground faults by means of the ground fault circuit interrupter (g...

  • Page 14: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 14 i n c o r p o r a t e d 8 installation 8.1 unpacking the inverter inspect the shipping container and equipment for loose or damaged parts. If any damage is found, immediately notify the freight carrier. 8.2 inverter insta...

  • Page 15: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 15 i n c o r p o r a t e d the wiring of your inverter installation should conform to the national electric code (nec) and any other state or local codes in effect at the time of installation. Article 551 of the nec requires...

  • Page 16: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 16 i n c o r p o r a t e d system on system off fault standby/ bulk charge power on ac power control 1 2 note: failure to connect these cables correctly may void your warranty. Go back to the inverter and connect the positiv...

  • Page 17: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 17 i n c o r p o r a t e d cut surface material large enough to accommodate the remote cable connector and board area leaving sufficient surface material to attach panel with #8 mounting screws. 8.3.1 route the 10-ft. Interf...

  • Page 18: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 18 i n c o r p o r a t e d 12. Disconnect the ac shore power input. The ac output test light blinks shortly, indicating the operation of the transfer switch connection to connect the ac loads to the inverter output. 13. The ...

  • Page 19: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 19 i n c o r p o r a t e d battery accepts charge, the battery voltage will rise to the charger's bulk voltage value, 14.4 vdc for flooded batteries, or 14.1 vdc for gel batteries. When battery voltage reaches the bulk volta...

  • Page 20: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 20 i n c o r p o r a t e d ac input voltage is monitored for proper tolerance at all times. When the ac input is within tolerance for approximately 5 seconds, the power is passed through to the output circuit and the src12-1...

  • Page 21: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 21 i n c o r p o r a t e d symptom inverter light does not illuminate solution reset on/off switch on unit and remote disconnect remote switch and attempt starting with unit on/off switch check dc fuse condition verify batte...

  • Page 22: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 22 i n c o r p o r a t e d 12 appendices 12.1 problem loads although modified sine wave inverters will operate most ac loads, some loads may exhibit problems because the waveform is different than the pure sine wave of utili...

  • Page 23: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 23 i n c o r p o r a t e d 12.6 dc power consumption an inverter takes in dc power, and produces ac power to operate attached loads. In general, we can see a direct relationship between dc input power and ac output power. Th...

  • Page 24: Owner'S Manual - D913482

    Owner's manual - d913482 src12-1200l/s inverter/charger 10/31/08 - 10:20 am 24 i n c o r p o r a t e d vanner incorporated 4282 reynolds drive hilliard, ohio 43026 1-800-ac power (1-800-227-6937) tel: 614-771-2718 fax: 614-771-4904 www.Vanner.Com e-mail: pwrsales@vanner.Com manual part number d91348...