Thank you for purchasing a weber ® barbecue. Now take a few minutes and protect it by registering your product online at www.Weber.Com. ® barbecue installation guide universal liquefied petroleum gas 57991 au - australia nz - new zealand 04/01/15 important! If you are installing this barbecue into a...
2 www.Weber.Com ® warnings m danger failure to follow the dangers, warnings, and cautions contained in this owner’s guide may result in serious bodily injury or death, or may result in a fire or an explosion causing damage to property. Warnings: m improper assembly of barbecue may be dangerous. Plea...
Www.Weber.Com ® 3 table of contents warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 table of contents . . . . . . . . . . . . . . . . . . . . . . . . 3 parts list . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 planning ahead . . . . . . . . . . . . . . ....
4 www.Weber.Com ® ........................................1 ......................................1 .......................................1 ........................................1 ...............................1 .................................1 ..................................... 2 ............
Www.Weber.Com ® 5 planning ahead considerations for locating your barbecue any enclosure in which the appliance is used shall comply with one of the following: • an enclosure with walls on all sides, but at least one permanent opening at ground level and no overhead cover (1). • within a partial enc...
6 www.Weber.Com ® recommended gas supply location it is important to consider the proximity of the barbecue (1) to the gas supply (2) of your built-in barbecue structure. The gas supply needs to be located directly below the right side of the barbecue, or to the right of the barbecue within the stru...
Www.Weber.Com ® 7 planning ahead consider all of the following dimensions to help determine space limitations and the best location for your barbecue installation. Barbecue dimensions the q ® 3600™ built-in gas barbecue is designed for easy installation in new and existing built-in masonry structure...
8 www.Weber.Com ® clearances from combustible materials 2 2 2 1 1 q ® 3600 ™ cookbox 2 457 mm (18") from edge of cookbox to any combustible surface required clearances from combustible materials clearance dimensions indicate the minimum allowable distance from the edge of the cookbox to any combusti...
Www.Weber.Com ® 9 planning the lpg cylinder compartment the lpg cylinder compartment shall house the included hose and regulator assembly. The hose and regulator are required parts of the q ® 3600™ built-in gas barbecue. A properly constructed cylinder compartment meets the requirements for venting ...
10 www.Weber.Com ® construction details locating the structure near a combustible wall 9 4 5 9 7 2 5 1 2 3 8 d c 6 6 8 7 10 1 b a dimensions description 1 813 mm (32") minimum countertop height. 2 597 mm (23 1 ⁄ 2 ") minimum countertop depth. Allow 20 mm ( 3 ⁄ 4 ") for typical countertop overhang. (...
Www.Weber.Com ® 11 construction details locating the structure near a noncombustible wall 9 1 9 7 d b c 7 6 6 8 1 2 2 5 8 10 4 5 3 a dimensions description 1 813 mm (32") minimum countertop height. 2 597 mm (23 1 ⁄ 2 ") minimum countertop depth. Allow 20 mm ( 3 ⁄ 4 ") for typical countertop overhang...
12 www.Weber.Com ® preparing your barbecue for a leak check place the q ® 3600 ™ built-in gas barbecue assembly on a table or other stable raised surface. Place the lpg cylinder on the ground next to the table. This will enable you to safely connect the barbecue to the lpg cylinder outside of your b...
Www.Weber.Com ® 13 remove the cookbox a) remove the left and right cookbox retainer thumb screws (1). B) slide cookbox retainers towards you (2). C) lift the cookbox out of the stainless steel cabinet (3) and disconnect the igniter wires (4) from the ignition module. Carefully set the cookbox aside....
14 www.Weber.Com ® m danger do not use an open flame to check for gas leaks. Be sure that there are no sparks or open flames in the area while you check for leaks. Sparks or open flames will result in a fire or explosion, which can cause serious bodily injury or death and damage to property. Checkin...
Www.Weber.Com ® 15 2 1 preparing to install reassembly for permanent installation disconnect gas supply m caution: you must disconnect the gas supply at the pol coupling. A) close the lpg cylinder valve by turning it clockwise (1). B) unscrew the regulator by turning the pol coupling clockwise by ha...
16 www.Weber.Com ® 14 16 17 9 8 11 12 13 15 10 preparing to install reinstall burner tubes you will need: a 3/8" nut driver. A) while holding the inside burner tube with the mounting bracket rotated up 90° (8), carefully slide the burner tube back into the hole on the right side of cookbox (9). Look...
Www.Weber.Com ® 17 installation test fitting the barbecue into the structure a) carefully feed hose and regulator through opening in your barbecue structure (1), and set the barbecue unit into place. B) make sure that the barbecue unit is centered in the opening, and that the surface of the countert...
18 www.Weber.Com ® final assembly 1 2 2- 2-.
Www.Weber.Com ® 19 final assembly 3 1- 2- 4.
20 www.Weber.Com ® final assembly 6 2- 5.
Www.Weber.Com ® 21 final assembly aaa aaa 1- 2- 7 8 9 aaa aaa.
22 www.Weber.Com ® 6 5 3 2 4 1 final gas supply connection connecting the hose / regulator to the lpg cylinder now that your barbecue is installed and fully assembled, it is time to make the final gas connection. A) check that both burner control knobs are in the off ( ) position by pushing burner c...
Www.Weber.Com ® 23.
Weber-stephen products llc www.Weber.Com © 2015 designed and engineered by weber-stephen products llc, 200 east daniels road, palatine, illinois 60067 u.S.A. M attention: this product has been safety tested and is only certified for use in a specific country. Refer to country designation located on ...
