Weber 3600 Installation Manual - page 12
12
WWW.WEBER.COM
®
PREPARING YOUR BARBECUE FOR A LEAK
CHECK
Place the Q
®
3600
™
built-in gas barbecue assembly on
a table or other stable raised surface. Place the LPG
cylinder on the ground next to the table. This will enable
you to safely connect the barbecue to the LPG cylinder
outside of your built-in structure and perform a leak
check.
Partial Disassembly of the Barbecue
To perform a complete leak check, it is necessary to
remove the cookbox to gain access to the gas train.
A) Install control knobs (1).
B) Check that BOTH burner control knobs are in the off
( ) position
(2). Burner controls are shipped in the
off ( ) position, but you should be sure that they are
turned off. Verify by pushing burner control knobs
in and turning them clockwise. If they do not turn,
they are off. If they do turn, continue turning them
clockwise until they stop.
C) Remove the control knobs and set aside.
Remove Burner Tubes
You will need: A 3/8" nut driver.
A) Remove the screw that secures the outside burner
tube to the cookbox (3).
B) Rotate the outside burner tube 90° (4) to unlock
it from the valve orifice. Looking through the
view port (5) slide the burner tube away from the valve
orifice (6) and remove from cookbox (7).
C) Remove the screw that secures the inside burner tube
to the cookbox (8).
D) Rotate the inside burner tube 90° (9) to unlock it
from the valve orifice. Looking through the view port
again (5), slide the burner tube away from the valve
orifice (6) and remove from cookbox.
m CAUTION: Care must be taken when
removing or reinstalling burner tubes.
Do not force or bend the gas lines within
the manifold assembly.
PREPARING TO INSTALL
4
6
5
2
7
9
3
8
1
PERFORMING A LEAK
CHECK BEFORE
INSTALLATION
All factory made connections
have been thoroughly checked
for gas leaks. The burners
have been flame tested. As a
safety precaution, however,
you should recheck all fittings
for leaks before using your
Weber
®
gas barbecue. Gas
fittings can become loose or
damaged during shipping.