AirPac COOLIT3000 Instruction Manual - page 9
AirPac’s patent-pending condensate removal system is the
best in the industry. During cooling operations and when hu-
midity conditions are above 50%, condensate is generated and
must be removed from the unit . Our condensate removal sys-
tem is selectable in the field and can be changed as your cool-
ing needs require. You can select from the following three
methods:
TANKS—Condensate is collected into the tanks. When
the tanks are full the water must be emptied.
AUTOMATIC—Condensate is pumped from the pump
reservoir through a vinyl tube out of the unit to a drain.
GRAVITY—Condensate drains from the unit by flow of
gravity to a drain outside of unit.
The condensate pump is wired and an operational component
in the condensate drain system, whether you select to use the
manual tank draining system or automatic removal method.
The COOLIT3000 leaves the factory ready for manual tank
draining.
1.
The dual tanks will fill up at approximately the same
rate. When the dual 2.5 gallon condensate tanks are
full, the TANK FULL alarm will flicker and an audible
alarm will beep. Open the front door and remove the
plug from the socket for each condensate tank.
2.
Empty the tanks and replace the tanks and plugs back
into sockets. They only fit one way.
3.
Close the door. The tank full alarm should clear.
You may find that your COOLIT3000 continues to operate
while you are emptying the condensate tanks. This is nor-
mal. When the condensate pump reservoir reaches the full
level, power to the compressor and fans shut off so conden-
sate does not overflow. The tank full alarm will activate too.
13
REMOVING THE CONDENSATE
Unequalled
Versatility
Manual Tank
Draining
TANK FULL alarm. Flickers and beeps on any of these
conditions: front door open—not latched; tank(s) full; tank
plug not in place; or condensate pump emergency shut off
(fans and compressor are disabled). Turn unit off, clear tank
fault, and restart norm al operation.
NOTE:
Recessed Storage
Compartment for
Power Cord
Condenser Air
Filter
(service access)
UNIT OVERVIEW—COOLIT 3000
REAR VIEW
Casters
6