- DL manuals
- Jabiru
- Engine
- 2200
- Maintenance Manual
Jabiru 2200 Maintenance Manual - 8 Maintenance
Engine Maintenance Manual
Jabiru Aircraft
Pty Ltd
JEM0002-5
Jabiru 2200 & 3300 Aircraft Engines
This document is controlled while it remains on the Jabiru server. Once this no longer applies the document becomes uncontrolled.
ISSUE
1
2
3
4
5
Dated : 2nd June 2015
Issued By: AS
Page: 45 of 103
L:\files\Manuals_For_Products\Engine_Manuals\Engine Maintenance Manual 22 & 33\JEM0002-5.docx
8 MAINTENANCE
8.1
Service Interval Tolerance
A tolerance of plus or minus 3 hours is allowable on all service intervals set within this manual
Engine life is measured via direct tachometer hour meters or “Hobbs” meters. Air switches or
scaled hour readings based on cumulative power output are not to be used to determine when
overhauls or services are due.
8.2
Basic Inspection Procedure
Test run engine: record anomalies.
Remove the engine cowlings and inspect the engine bay in “dirty” condition.
Clean the engine bay & propeller
Carry out the inspections listed in Table 13.
Test and re-assemble the aircraft. Test fly if required.
8.3
Work Sheets
Work sheets designed to suit the inspections below are included in Section 11. These sheets
are designed to be fast to fill out and to give all required detail from a particular inspection
when affixed in the log book.
The use of these worksheets by maintainers is strongly recommended.
8.4
Mandatory Inspections & Lifed Items.
Engine life is as noted in Section 9.25.
Lifed components of the engine are detailed in the Engine Overhaul Manual.
Mandatory inspections are detailed in Table 13.
8.4.1 Flexible Hoses
All flexible hoses in the engine compartment should be replaced at engine overhaul or every 2
years whichever comes first. Hoses which show visible deterioration (cracking, excessive
hardening) should be replaced immediately, irrespective of age.
8.5
Engine Inspection Chart
The chart below shows the recommended intervals at which items are to be inspected.
Additional detail of the maintenance required for each point is given in the sections below the
inspection chart.
As shown in the chart, there are items to be inspected each 25 hours, 50 hours, 100 hours,
each 200 hours and Annually. There are also special inspection items that require inspection
or servicing at intervals other than those in the normal inspection chart.
At 50 hour inspections all items marked under Each 25 Hours are inspected, serviced or
otherwise completed in addition to the items marked under Each 50 Hours.
When conducting an inspection at 100 hours, all items marked under Each 25 Hours & Each
50 Hours are inspected, serviced or otherwise completed in addition to the items marked
under Each 100 Hours.
At each 200 hours inspection the 25 Hour, 50 Hour & 100 hour items are completed in
addition to the items marked under Each 200 Hours.
An inspection conducted Annually would likewise include the 25, 50, 100 and 200 hour items in
addition to the items marked under Annual Inspection.
A complete aircraft inspection includes all 25, 50, 100, 200 hour and Annual items together
with those shown in the Aircraft Technical Manual and Propeller Manual.
Summary of 2200
Page 1
Maintenance manual for jabiru 2200 aircraft engine jabiru 3300 aircraft engine document no. Jem0002-5 dated: 2 nd june 2015 this manual has been prepared as a guide to correctly operate, maintain and service jabiru 2200 & 3300 engines. It is the owner's responsibility to regularly check the jabiru w...
Page 2
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 2 of 103 l:\file...
Page 3
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 3 of 103 l:\file...
Page 4
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 4 of 103 l:\file...
Page 5
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 5 of 103 l:\file...
Page 6: 2 General Information
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 6 of 103 l:\file...
Page 7
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 7 of 103 l:\file...
Page 8
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 8 of 103 l:\file...
Page 9
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 9 of 103 l:\file...
Page 10
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 10 of 103 l:\fil...
Page 11
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 11 of 103 l:\fil...
Page 12: 3 Specifications
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 12 of 103 l:\fil...
Page 13
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 13 of 103 l:\fil...
Page 14
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 14 of 103 l:\fil...
Page 15
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 15 of 103 l:\fil...
Page 16
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 16 of 103 l:\fil...
Page 17
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 17 of 103 l:\fil...
Page 18
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 18 of 103 l:\fil...
Page 19
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 19 of 103 l:\fil...
Page 20
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 20 of 103 l:\fil...
Page 21
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 21 of 103 l:\fil...
Page 22
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 22 of 103 l:\fil...
Page 23
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 23 of 103 l:\fil...
Page 24
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 24 of 103 l:\fil...
Page 25
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 25 of 103 l:\fil...
Page 26: Airworthiness Limitations
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines casa approved section airworthiness limitations this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2n...
Page 27: 5 Operating Instructions
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 27 of 103 l:\fil...
Page 28
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 28 of 103 l:\fil...
Page 29
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 29 of 103 l:\fil...
Page 30
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 30 of 103 l:\fil...
Page 31: 6 Maintainer Requirements
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 31 of 103 l:\fil...
Page 32
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 32 of 103 l:\fil...
Page 33
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 33 of 103 l:\fil...
Page 34
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 34 of 103 l:\fil...
Page 35
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 35 of 103 l:\fil...
Page 36
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 36 of 103 l:\fil...
Page 37
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 37 of 103 l:\fil...
Page 38
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 38 of 103 l:\fil...
Page 39
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 39 of 103 l:\fil...
Page 40
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 40 of 103 l:\fil...
Page 41
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 41 of 103 l:\fil...
Page 42: 7 Storage & Cleaning
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 42 of 103 l:\fil...
Page 43
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 43 of 103 l:\fil...
Page 44
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 44 of 103 l:\fil...
Page 45: 8 Maintenance
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 45 of 103 l:\fil...
Page 46
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 46 of 103 l:\fil...
Page 47
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 47 of 103 l:\fil...
Page 48
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 48 of 103 l:\fil...
Page 49
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 49 of 103 l:\fil...
Page 50
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 50 of 103 l:\fil...
Page 51
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 51 of 103 l:\fil...
Page 52
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 52 of 103 l:\fil...
Page 53
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 53 of 103 l:\fil...
Page 54
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 54 of 103 l:\fil...
Page 55
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 55 of 103 l:\fil...
Page 56
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 56 of 103 l:\fil...
Page 57
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 57 of 103 l:\fil...
Page 58
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 58 of 103 l:\fil...
Page 59
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 59 of 103 l:\fil...
Page 60
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 60 of 103 l:\fil...
Page 61
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 61 of 103 l:\fil...
Page 62
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 62 of 103 l:\fil...
Page 63
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 63 of 103 l:\fil...
Page 64
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 64 of 103 l:\fil...
Page 65
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 65 of 103 l:\fil...
Page 66
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 66 of 103 l:\fil...
Page 67
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 67 of 103 l:\fil...
Page 68
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 68 of 103 l:\fil...
Page 69
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 69 of 103 l:\fil...
Page 70
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 70 of 103 l:\fil...
Page 71
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 71 of 103 l:\fil...
Page 72
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 72 of 103 l:\fil...
Page 73
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 73 of 103 l:\fil...
Page 74
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 74 of 103 l:\fil...
Page 75
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 75 of 103 l:\fil...
Page 76
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 76 of 103 l:\fil...
Page 77
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 77 of 103 l:\fil...
Page 78
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 78 of 103 l:\fil...
Page 79
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 79 of 103 l:\fil...
Page 80
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 80 of 103 l:\fil...
Page 81
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 81 of 103 l:\fil...
Page 82: 10 Trouble Shooting
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 82 of 103 l:\fil...
Page 83
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 83 of 103 l:\fil...
Page 84
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 84 of 103 l:\fil...
Page 85
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 85 of 103 l:\fil...
Page 86
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 86 of 103 l:\fil...
Page 87
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 87 of 103 l:\fil...
Page 88
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 88 of 103 l:\fil...
Page 89
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 89 of 103 ...
Page 90
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 90 of 103 ...
Page 91
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 91 of 103 ...
Page 92
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 92 of 103 ...
Page 93
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 93 of 103 ...
Page 94: 12 New Engine
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 94 of 103 ...
Page 95
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 95 of 103 ...
Page 96
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 96 of 103 ...
Page 97
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 97 of 103 ...
Page 98
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 98 of 103 ...
Page 99
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 99 of 103 ...
Page 100
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 100 of 103...
Page 101: 14 Revisions
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 101 of 103...
Page 102: 15 Feedback And Reporting
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 102 of 103...
Page 103
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 103 of 103...