- DL manuals
- Jabiru
- Engine
- 2200
- Maintenance Manual
Jabiru 2200 Maintenance Manual - page 75
Engine Maintenance Manual
Jabiru Aircraft
Pty Ltd
JEM0002-5
Jabiru 2200 & 3300 Aircraft Engines
This document is controlled while it remains on the Jabiru server. Once this no longer applies the document becomes uncontrolled.
ISSUE
1
2
3
4
5
Dated : 2nd June 2015
Issued By: AS
Page: 75 of 103
L:\files\Manuals_For_Products\Engine_Manuals\Engine Maintenance Manual 22 & 33\JEM0002-5.docx
When using double-twist method of safety wiring, 0.032 inch minimum diameter wire should be
used on parts that have a hole diameter larger than 0.045 inch (1.1mm). When using the
single-wire method, the largest size wire that the hole will accommodate should be used.
CAUTION
Care must be taken not to confuse steel with Aluminium wire.
There are many combinations of safety wiring with certain basic rules common to all
applications. These rules are as follows.
a. When bolts, screws, or other parts are closely grouped, it is more convenient to safety wire
them in series. The number of bolts, nuts, screws, etc., that may be wired together depends
on the application.
b. Drilled boltheads and screws need not be safety wired if installed with self-locking nuts.
c. To prevent failure due to rubbing or vibration, safety wire must be tight after installation.
d. Safety wire must be installed in a manner that will prevent the tendency of the part to
loosen.
e. Safety wire must never be over-stressed. Safety wire will break under vibrations if twisted
too tightly. Safety wire must be pulled taut when being twisted, and maintain a light tension
when secured (Figure 46).
f. Safety-wire ends must be bent under and inward toward the part to avoid sharp or
projecting ends, which might present a safety hazard.
g. Safety wire inside a duct or tube must not cross over or obstruct a flow passage when an
alternate routing can be used.
h. Check the units to be safety wired to make sure that they have been correctly torqued, and
that the wiring holes are properly aligned to each other. When there are two or more units,
it is desirable that the holes in the units be aligned to each other. Never over-torque or
loosen to obtain proper alignment of the holes. It should be possible to align the wiring
holes when the bolts are torqued within the specified limits. However, if it is impossible to
obtain a proper alignment of the holes without under-torquing or over-torquing, try another
bolt which will permit proper alignment within the specified torque limits.
i. To prevent mutilation of the twisted section of wire, when using pliers, grasp the wires at
the ends. Safety wire must not be nicked, kinked, or mutilated. Never twist the wire ends off
with pliers; and, when cutting off ends, leave at least four to six complete turns (1/2 to 5/8
inch long) after the loop. When removing safety wire, never twist the wire off with pliers. Cut
the safety wire close to the hole, exercising caution.
j. Install safety wire where practicable with the wire positioned around the head of the bolt,
screw, or nut, and twisted in such a manner that the loop of the wire fits closely to the
contour of the unit being safety wired.
When using a wire twister (safety wire pliers), grip the wire in the jaws of the wire twister and
slide the outer sleeve down with your thumb to lock the handles or lock the spring-loaded pin.
Pull the knob, and the spiral rod spins and twists the wire.
Squeeze handles together to release wire.
CAUTION
When using wire twisters, and the wire extends 3 inches beyond the jaws of the twisters,
loosely wrap the wire around the pliers to prevent whipping and possible personal injury.
Excessive twisting of the wire will weaken the wire.
Summary of 2200
Page 1
Maintenance manual for jabiru 2200 aircraft engine jabiru 3300 aircraft engine document no. Jem0002-5 dated: 2 nd june 2015 this manual has been prepared as a guide to correctly operate, maintain and service jabiru 2200 & 3300 engines. It is the owner's responsibility to regularly check the jabiru w...
Page 2
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 2 of 103 l:\file...
Page 3
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 3 of 103 l:\file...
Page 4
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 4 of 103 l:\file...
Page 5
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 5 of 103 l:\file...
Page 6: 2 General Information
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 6 of 103 l:\file...
Page 7
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 7 of 103 l:\file...
Page 8
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 8 of 103 l:\file...
Page 9
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 9 of 103 l:\file...
Page 10
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 10 of 103 l:\fil...
Page 11
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 11 of 103 l:\fil...
Page 12: 3 Specifications
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 12 of 103 l:\fil...
Page 13
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 13 of 103 l:\fil...
Page 14
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 14 of 103 l:\fil...
Page 15
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 15 of 103 l:\fil...
Page 16
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 16 of 103 l:\fil...
Page 17
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 17 of 103 l:\fil...
Page 18
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 18 of 103 l:\fil...
Page 19
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 19 of 103 l:\fil...
Page 20
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 20 of 103 l:\fil...
Page 21
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 21 of 103 l:\fil...
Page 22
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 22 of 103 l:\fil...
Page 23
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 23 of 103 l:\fil...
Page 24
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 24 of 103 l:\fil...
Page 25
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 25 of 103 l:\fil...
Page 26: Airworthiness Limitations
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines casa approved section airworthiness limitations this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2n...
Page 27: 5 Operating Instructions
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 27 of 103 l:\fil...
Page 28
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 28 of 103 l:\fil...
Page 29
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 29 of 103 l:\fil...
Page 30
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 30 of 103 l:\fil...
Page 31: 6 Maintainer Requirements
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 31 of 103 l:\fil...
Page 32
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 32 of 103 l:\fil...
Page 33
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 33 of 103 l:\fil...
Page 34
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 34 of 103 l:\fil...
Page 35
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 35 of 103 l:\fil...
Page 36
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 36 of 103 l:\fil...
Page 37
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 37 of 103 l:\fil...
Page 38
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 38 of 103 l:\fil...
Page 39
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 39 of 103 l:\fil...
Page 40
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 40 of 103 l:\fil...
Page 41
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 41 of 103 l:\fil...
Page 42: 7 Storage & Cleaning
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 42 of 103 l:\fil...
Page 43
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 43 of 103 l:\fil...
Page 44
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 44 of 103 l:\fil...
Page 45: 8 Maintenance
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 45 of 103 l:\fil...
Page 46
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 46 of 103 l:\fil...
Page 47
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 47 of 103 l:\fil...
Page 48
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 48 of 103 l:\fil...
Page 49
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 49 of 103 l:\fil...
Page 50
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 50 of 103 l:\fil...
Page 51
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 51 of 103 l:\fil...
Page 52
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 52 of 103 l:\fil...
Page 53
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 53 of 103 l:\fil...
Page 54
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 54 of 103 l:\fil...
Page 55
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 55 of 103 l:\fil...
Page 56
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 56 of 103 l:\fil...
Page 57
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 57 of 103 l:\fil...
Page 58
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 58 of 103 l:\fil...
Page 59
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 59 of 103 l:\fil...
Page 60
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 60 of 103 l:\fil...
Page 61
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 61 of 103 l:\fil...
Page 62
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 62 of 103 l:\fil...
Page 63
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 63 of 103 l:\fil...
Page 64
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 64 of 103 l:\fil...
Page 65
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 65 of 103 l:\fil...
Page 66
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 66 of 103 l:\fil...
Page 67
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 67 of 103 l:\fil...
Page 68
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 68 of 103 l:\fil...
Page 69
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 69 of 103 l:\fil...
Page 70
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 70 of 103 l:\fil...
Page 71
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 71 of 103 l:\fil...
Page 72
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 72 of 103 l:\fil...
Page 73
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 73 of 103 l:\fil...
Page 74
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 74 of 103 l:\fil...
Page 75
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 75 of 103 l:\fil...
Page 76
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 76 of 103 l:\fil...
Page 77
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 77 of 103 l:\fil...
Page 78
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 78 of 103 l:\fil...
Page 79
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 79 of 103 l:\fil...
Page 80
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 80 of 103 l:\fil...
Page 81
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 81 of 103 l:\fil...
Page 82: 10 Trouble Shooting
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 82 of 103 l:\fil...
Page 83
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 83 of 103 l:\fil...
Page 84
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 84 of 103 l:\fil...
Page 85
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 85 of 103 l:\fil...
Page 86
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 86 of 103 l:\fil...
Page 87
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 87 of 103 l:\fil...
Page 88
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 88 of 103 l:\fil...
Page 89
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 89 of 103 ...
Page 90
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 90 of 103 ...
Page 91
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 91 of 103 ...
Page 92
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 92 of 103 ...
Page 93
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 93 of 103 ...
Page 94: 12 New Engine
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 94 of 103 ...
Page 95
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 95 of 103 ...
Page 96
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 96 of 103 ...
Page 97
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 97 of 103 ...
Page 98
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 98 of 103 ...
Page 99
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 99 of 103 ...
Page 100
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 100 of 103...
Page 101: 14 Revisions
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 101 of 103...
Page 102: 15 Feedback And Reporting
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 102 of 103...
Page 103
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 103 of 103...