- DL manuals
- Jabiru
- Engine
- 2200
- Maintenance Manual
Jabiru 2200 Maintenance Manual - page 67
Engine Maintenance Manual
Jabiru Aircraft
Pty Ltd
JEM0002-5
Jabiru 2200 & 3300 Aircraft Engines
This document is controlled while it remains on the Jabiru server. Once this no longer applies the document becomes uncontrolled.
ISSUE
1
2
3
4
5
Dated : 2nd June 2015
Issued By: AS
Page: 67 of 103
L:\files\Manuals_For_Products\Engine_Manuals\Engine Maintenance Manual 22 & 33\JEM0002-5.docx
Tensioning is carried out when the engine is cold.
Torque the screws in the order shown in Figure 39.
Note any screws which require more than 1/4 - 1/3 of a turn to reach the set tension as this
may be an indication of issues such as excess temperature in service.
Re-fit the 1/8 NPT plug to close the access hole to the bottom head bolt. Torque to the setting
given in Table 10.
Re-fit the rocker cover to the head, ensuring that the seal is correctly positioned in the groove
in the head.
Re-fit the ram air cooling ducts.
CAUTION
Do not over-tighten. Over-tightening will eventually loosen fit between plug & head to the
point where the plug will not be secure.
Figure 39
– Head Bolt Locations
9.16
Inspect Valve Springs & Rockers
Required Tools:
Tools as required in section 9.15
Vernier Calipers
Parts and Material:
Replacement valve spring washers (if required)
Type of Maintenance:
Heavy Maintenance
Level of Certification:
L2 or LAME (A&P or LSA Repairman / Maintenance)
Return to Service:
L2 or LAME (A&P or LSA Repairman / Maintenance)
While the rocker cover is removed for the cylinder head bolt tension check (Section 9.15),
visually inspect the components inside the rocker chest:
1. Visually check for wear or damage to the rocker and valve stem tip.
2. Visually check for wear or damage to the valve spring.
3. Measure the thickness of the upper valve spring washer as shown in Figure 40. Any
measurement below 1.3mm must be investigated and worn parts replaced; failure typically
occurs at around 1.0mm.
4. When all parts have been inspected re-assemble the engine.
1
2
6
4
5
3
Summary of 2200
Page 1
Maintenance manual for jabiru 2200 aircraft engine jabiru 3300 aircraft engine document no. Jem0002-5 dated: 2 nd june 2015 this manual has been prepared as a guide to correctly operate, maintain and service jabiru 2200 & 3300 engines. It is the owner's responsibility to regularly check the jabiru w...
Page 2
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 2 of 103 l:\file...
Page 3
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 3 of 103 l:\file...
Page 4
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 4 of 103 l:\file...
Page 5
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 5 of 103 l:\file...
Page 6: 2 General Information
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 6 of 103 l:\file...
Page 7
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 7 of 103 l:\file...
Page 8
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 8 of 103 l:\file...
Page 9
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 9 of 103 l:\file...
Page 10
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 10 of 103 l:\fil...
Page 11
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 11 of 103 l:\fil...
Page 12: 3 Specifications
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 12 of 103 l:\fil...
Page 13
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 13 of 103 l:\fil...
Page 14
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 14 of 103 l:\fil...
Page 15
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 15 of 103 l:\fil...
Page 16
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 16 of 103 l:\fil...
Page 17
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 17 of 103 l:\fil...
Page 18
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 18 of 103 l:\fil...
Page 19
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 19 of 103 l:\fil...
Page 20
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 20 of 103 l:\fil...
Page 21
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 21 of 103 l:\fil...
Page 22
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 22 of 103 l:\fil...
Page 23
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 23 of 103 l:\fil...
Page 24
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 24 of 103 l:\fil...
Page 25
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 25 of 103 l:\fil...
Page 26: Airworthiness Limitations
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines casa approved section airworthiness limitations this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2n...
Page 27: 5 Operating Instructions
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 27 of 103 l:\fil...
Page 28
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 28 of 103 l:\fil...
Page 29
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 29 of 103 l:\fil...
Page 30
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 30 of 103 l:\fil...
Page 31: 6 Maintainer Requirements
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 31 of 103 l:\fil...
Page 32
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 32 of 103 l:\fil...
Page 33
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 33 of 103 l:\fil...
Page 34
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 34 of 103 l:\fil...
Page 35
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 35 of 103 l:\fil...
Page 36
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 36 of 103 l:\fil...
Page 37
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 37 of 103 l:\fil...
Page 38
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 38 of 103 l:\fil...
Page 39
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 39 of 103 l:\fil...
Page 40
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 40 of 103 l:\fil...
Page 41
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 41 of 103 l:\fil...
Page 42: 7 Storage & Cleaning
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 42 of 103 l:\fil...
Page 43
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 43 of 103 l:\fil...
Page 44
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 44 of 103 l:\fil...
Page 45: 8 Maintenance
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 45 of 103 l:\fil...
Page 46
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 46 of 103 l:\fil...
Page 47
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 47 of 103 l:\fil...
Page 48
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 48 of 103 l:\fil...
Page 49
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 49 of 103 l:\fil...
Page 50
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 50 of 103 l:\fil...
Page 51
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 51 of 103 l:\fil...
Page 52
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 52 of 103 l:\fil...
Page 53
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 53 of 103 l:\fil...
Page 54
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 54 of 103 l:\fil...
Page 55
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 55 of 103 l:\fil...
Page 56
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 56 of 103 l:\fil...
Page 57
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 57 of 103 l:\fil...
Page 58
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 58 of 103 l:\fil...
Page 59
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 59 of 103 l:\fil...
Page 60
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 60 of 103 l:\fil...
Page 61
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 61 of 103 l:\fil...
Page 62
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 62 of 103 l:\fil...
Page 63
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 63 of 103 l:\fil...
Page 64
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 64 of 103 l:\fil...
Page 65
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 65 of 103 l:\fil...
Page 66
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 66 of 103 l:\fil...
Page 67
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 67 of 103 l:\fil...
Page 68
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 68 of 103 l:\fil...
Page 69
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 69 of 103 l:\fil...
Page 70
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 70 of 103 l:\fil...
Page 71
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 71 of 103 l:\fil...
Page 72
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 72 of 103 l:\fil...
Page 73
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 73 of 103 l:\fil...
Page 74
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 74 of 103 l:\fil...
Page 75
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 75 of 103 l:\fil...
Page 76
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 76 of 103 l:\fil...
Page 77
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 77 of 103 l:\fil...
Page 78
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 78 of 103 l:\fil...
Page 79
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 79 of 103 l:\fil...
Page 80
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 80 of 103 l:\fil...
Page 81
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 81 of 103 l:\fil...
Page 82: 10 Trouble Shooting
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 82 of 103 l:\fil...
Page 83
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 83 of 103 l:\fil...
Page 84
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 84 of 103 l:\fil...
Page 85
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 85 of 103 l:\fil...
Page 86
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 86 of 103 l:\fil...
Page 87
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 87 of 103 l:\fil...
Page 88
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 88 of 103 l:\fil...
Page 89
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 89 of 103 ...
Page 90
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 90 of 103 ...
Page 91
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 91 of 103 ...
Page 92
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 92 of 103 ...
Page 93
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 93 of 103 ...
Page 94: 12 New Engine
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 94 of 103 ...
Page 95
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 95 of 103 ...
Page 96
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 96 of 103 ...
Page 97
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 97 of 103 ...
Page 98
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 98 of 103 ...
Page 99
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 99 of 103 ...
Page 100
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 100 of 103...
Page 101: 14 Revisions
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 101 of 103...
Page 102: 15 Feedback And Reporting
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 102 of 103...
Page 103
Engine maintenance manual jabiru aircraft pty ltd jem0002-5 jabiru model 2200 & 3300 aircraft engines this document is controlled while it remains on the jabiru server. Once this no longer applies the document becomes uncontrolled. Issue 1 2 3 4 5 dated : 2nd june 2015 issued by: as page: 103 of 103...