110714-24 neo25 5055.900 installation and operating instructions safety notice if this stove is not properly installed, a house fi re may result. For your safety, follow the installation instructions. Contact local building or fire officials about restrictions and installation inspection requirement...
2 neo25 110714-24 please save these instructions note: we strongly recommend that smoke detectors be installed. If smoke detectors have been previously installed, you may notice that they are operating more frequently. This may be due to curing of stove paint or fumes caused by accidentally leaving ...
110714-24 neo25 3 creosote formation and need for removal when wood is burned slowly, it produces tar and other organic vapours, which combine with expelled moisture to form creosote. The creosote vapours condense in the relatively cool chimney fl ue of a slow burning fi re. As a result, creosote re...
4 neo25 110714-24 caution: never use gasoline, gasoline type lantern fuel, kerosene, charcoal lighter fl uid or similar liquids to start or "freshen up" a fi re in this heater. Keep all such liquids well away from the heater while it is in use. Caution: hot while in operation. Keep children, clothin...
110714-24 neo25 5 ash removal caution: ashes are to be removed only when the heater is cold. Whenever ashes get 3(76mm) to 4(102mm) inches deep in your fi rebox, and when fi re has burned down and cooled, remove excess ashes. Leave an ash bed approximately 1" (25 mm) deep on the fi rebox bottom to h...
6 neo25 110714-24 1. Burn wood only, dry and well seasoned. The denser or heavier the wood when dry, the greater its heat value. This is why hardwoods are generally preferred. Green or wet wood will cause a rapid buildup of creosote. If you feel it is necessary to burn wet or unseasoned wood, do so ...
110714-24 neo25 7 maintenance checks check the following parts for damage such as cracks, excessive corrosion, burned out sections and excessive warping: (see website for descriptions and more detail) some warping of the baffle is normal(up to 1/4” or 6mm). Replace if the baffle has permanent warpin...
8 neo25 110714-24 40 1/8" 1.02m 41" 1.04m 29" 737mm 22" 559mm 24 1/2" 622mm 6 1/8" 156mm neo 2.5 dimensions crate removal 1) carefully remove wood top and supports. 2) remove plastic cover. 3) using a 7/16"(12mm) wrench, remove lag bolts that secure stove body to bottom pallet. Side panel installati...
110714-24 neo25 9 4) attach the panel to the rear shield. Secure with two screws. Fig. #3 fig. #3 screws.
10 neo25 110714-24 8" [203mm] 16" [406mm] 8" [203mm] canada only ember protection the stove may be installed on a combustible fl oor provided ember protection made from a non-combustible material with a minimum k value of 23.7 btu/ft h ˚ f is used. This protection must extend as follows: in canada: ...
110714-24 neo25 11 warning: under no circumstances is this heater to be installed in a makeshift or "temporary" manner. It may be fi red only after the following conditions have been met. * do not attempt to connect this heater to any air distribution duct. * outside combustion air or fresh air into...
12 neo25 110714-24 15 5/8" 397mm 22 1/2" 572mm 8" 203mm 11" 279mm 5" 127mm 3" 76mm 3" 76mm mobile home minimum clearance to combustibles warning: under no circumstances is this heater to be installed in a makeshift or "temporary" manner. It may be fi red only after the following conditions have been...
110714-24 neo25 13 fig. #8 chimney storm collar * 4"(102mm) diameter air inlet with rodent screen * if the crawl space is well ventilated it is not necessary to extend air inlet to outside spark arrestor rain cap radiation shield chimney connector 44.5" (1130 mm) minimum minimum 7' (2.1m.) ceiling h...
14 neo25 110714-24 fig. #9 chimney * 4"(102mm) diameter air inlet with rodent screen * if the crawl space is well ventilated it is not necessary to extend air inlet to outside concrete cap chimney connector 12"(305mm) minimum fi rst section of pipe. Fireclay flue liner minimum 7' (2.1m.) ceiling hei...
110714-24 neo25 15 through wall installations system a. Minimum 3.5 in. (90 mm) thick brick masonry wall framed into combustible wall with a minimum of 12 in. (305 mm) brick separation from clay liner to combustibles. Fireclay liner (astm c 315, standard specifi cations for clay fire linings, or equ...
16 neo25 110714-24 optional blower the optional blower kit (wodc.Blow) is equipped with a three prong power cord and may be installed at any time. Follow installation instructions supplied with the kit. Route power supply cord away from heater. Electrical rating: 115 volts a.C., 60hz, .5 amps. Fan o...
110714-24 neo25 17 troubleshooting problem cause cure glass is dirty 1. Wood is wet - use dry wood 2. Turning down air control - do not turn down until or damper too soon a) there is a good bed of coals b) the wood is charred 3. Draft too low - improper chimney height and / or diameter - chimney plu...
18 neo25 110714-24 replacement parts - neo 2.5 (when ordering, include part number with description) item description part no. Item description part no. 2............ Embossed panel set .................... Ne25.78375xx 3............ Door catch .......................................... Ne25.7825 4....
110714-24 neo25 19 2. High mass and thermal insulation: the high mass (weight) acts as a heat storage and the thermal insulation keeps the combustion zone hot. Active fl aming takes place during the fi rst part of the burn. During this stage, heat is stored in the mass of the unit and is later relea...
20 neo25 110714-24 item/ article dimensions part number/ numÉro de piÈce a 9” x 4 1/2” x 1 1/4” (230 mm x 115 mm x 32 mm) 5096.99 b 2 1/8” x 9” x 1 1/4” (57 mm x 230 mm x 32 mm) 7847.3 c 4 1/8" x 4 1/2” x 1 1/4” (115 mm x 115 mm x 32 mm) 7847 d 2 1/8" x 4 1/2” x 1 1/4” (57mm x 115 mm x 32 mm) 7847.1...
110714-24 neo25 21.
22 neo25 110714-24.
110714-24 neo25 23 label a. 12 in. / 305 mm 12 in. / 305 mm b. 12 in. / 305 mm 12 in./305 mm c. 8 in. / 203 mm 8 in. / 203 mm d. 23.5 in. / 597 mm 23.5 in. / 597 mm e. 15 in. / 381 mm 15 in. / 381 mm f . 17 in. / 432 mm 17 in. / 432 mm a. 8 in. / 203 mm 8 in. / 203 mm b. 5 in. / 127 mm 5 in. / 127 m...
24 neo25 110714-24 pacific energy fireplace products ltd. 2975 allenby rd., duncan, b.C. V9l 6v8 phone: 250-748-1184 web site: http://www.Pacifi cenergy.Net printed in canada.
