WoodPro WS-TS-1500 Owner's Manual - page 15
VKſGF ChimnGy SwGGp, or a knoYNGFIGCbNG KPURGEVQr.
Consult your insur
CPEG EQORCny if you ECPPQV ſPF a
SWCNKſGF GZRGrt.
CAUTION: NOT ALL FIREPLACE CHIMNEYS
ARE SUITABLE FOR CONVERSIONTO ACCOM-
MODATE CONNECTION TO A WOOD STOVE.
CHECK WITH A QUALIFIED EXPERT.
Many pr
GfabriEatGF ſrGplaEGs arG of thG “zGro-
ENGCranEG ſTGplaEG” ECtGIory. ThGsG Eonsist of multi
lay
GrGF mGtal EonstruEtion. ThGy arG FGsiInGF with
GPQWIJ insulation CPFQT air EQQNKPI on VJG basG, baEk
CPF UKFGU so thGy ECP DG safGN[ KPUVCNNGF in FKTGEV EQP-
VCEV with EQObustibNG ƀQQTU CPF walls. #NVJQWIJ many
RTGfabrKECVGF ſTGRNCEGU ECTry GPFQTUGOGPVU from na-
tionally
TGEQIPKzGF QTICPK\CVKQPU for WUG as ſTGRNCEGs,
th
Gy havG not bGGP VGsVGF for EonnGEtion to woQF stovG
JGCVGTs. %QPPGEVKPI a stovG to UWEJ a FGXKEG will vQKF
VJGOCnufCEVWTGTŏs warranty.
V
GPVKPI a stovG FKTGEVN[ into a ſTGRNCEG FQGU not
m
GGt EQFG anF shoulF not bG attGmptGF. ThG stovG war-
ranty will b
G voiF with suEh an installation. Do not ErGatG
CJC\CTFKPyQWTJQOGb[EQPPGEVKPIKPVJKUOCPPGr.
FIREPLACE INSTALLATION
NOTE: DO NOT ATTEMPT TO ROUTE THE CHIM-
NEY CONNECTOR PIPETHROUGHTHETHROAT OF
THE FIREPLACE.
&KTGEVN[ EQPPGEVKPI VJG stovGRKRG
into
VJG GZKUVKPI masonry EJKOPGy ſIWTG 14 “T[RG A”
(KTGRNCEG ConvGTUKQP of VJG ſTGRNCEG is VJGONLY ap-
prov
GF mGthoF of installation. If thG EhimnGy is bGhinF a
EQObustibNG wall, you must WUG an approvGF wall pass-
VJTQWIJ U[UVGO to ICKP CEEGUU to VJG EJKOPGy. This is a
EompNKEatGF anF involvGF proEGss CPF to GnsurG safGty
UJQWNFQPN[DGFQPGb[CSWCNKſGFKPUVCNNGr.
1.
An
Gntry holG must bG Eut throuIh thG masonry anF
VKNG NKPGT with minimal FCOCIG to VJG NKPGr. At NGCUV
Figure 14 - Fireplace Conversion
8
Ŋ203mm of linGr must rGmain bGlow thG Gntry
position. Wh
Gn loEatinI thG stovG anF stovGpipG, all
minimum
ENGCrCPEGU must DG QDUGrvGF from EQO-
bustib
NG surfCEGs inENWFKPI mantGNs, EombustiblG
trim work,
EGKNKnIs, anF walls. PositioninI thG EGntGr
of
VJG stovG RKRG GPVry into VJG EJKOPGy ŊEO
DGNow VJG EGKNKPI UJQWNF KPUWTG RTQRGT ENGCrCPEG
f
QTCŊOOUVovGRKRG.
2.
Install a fir
G Elay (8Ŋ1mm minimum thiEk-
PGss thimblG. MakG surG thG thimblG is
ƀWUJ with VJG KPPGT surfCEG of VJG EJKOPGy NKPGT
CPF FQGU not protrWFG into VJG ƀWG UGG ſIWTG 9
QPRCIG
3.
S
GEurG thG thimblG with rGfraEtory mortar. ThG
thimbl
G shoulF bG surrounFGF by 12Ŋ30mm of
UQNKF unit masonry briEkwork or ŊEO of stonG.
4.
Install
VJG stovGRKRG into VJG thimbNG as far as pos-
sibl
G without GxtGnFinI past thG ƀuG lininI (sGG
ſIWTGUQPRCIGU.
A small airspaEG (about 12Ŋ13mm shoulF rGmain
b
GtwGGn thG stovGpipG anF thimblG to allow for
Gxpansion of VJG pipG. 5GCN this CKTURCEG with JKIJ
VGORGrCVWTGECWNMKPIQTEGrCOKEwool.
5GEWTG CPF UGCN VJG FCORGT in VJG ENQUGF posi-
tion usin
I hiIh-tGmp EaulkinI, EGramiE wool, or
fur
PCEG EGOGPV. Also EJGEk to UGG if VJG EJKOPGy
has a
ENGCP out. If it FQGs, makG UWTG it is ENQUGF
CPF UGCNGF as wGNN. A NGCM[ ENGCP out will ITGCVN[
TGFWEGFrCHVGHſEKGPEy.
If you hav
G any SWGUVKQPU TGICTFKPI vGPVKPI your
stov
G, EQPVCEV VJG manufCEVWTGT or EQPVCEV
VJG 0CVKQPCN(KTG 2TQVGEVKQP #UUQEKCVKQP (NFP#
CPF TGSWGUV a EQpy of VJG NCVGUV GFKVKQPU of NFPA
5VCPFCTF 211 CPF NFP#5VCPFCTF. 6JGKT
CFFTGUUKU$CVVGr[/CTEJParM3WKPEy/#
CHIMNEY CONNECTIONS
...continued
15