TATA Motors 2013 SAFARI STORME Owner's Manual & Service Book - page 121
IN CASE OF EMERGENCY
111
PRELIMINARY TROUBLE SHOOTING
PRELIMINARY TROUBLESHOOTING
(These tips are given for your guidance and preliminary jobs to be done in an emergency situation. In normal case, the problems
should be attended in an Authorised Workshop by following the repair procedures given in Workshop Manual)
SR. NO. PROBLEM OBSERVED
CAUSE
ACTION TO BE TAKEN
ENGINE
1.
Engine not cranking
Dead battery, loose, dirty connections
Charge / change the battery
Battery not getting charged from the alternator
Clean and tighten battery and alternator
connections
Starter motor relay damaged
Check battery to alternator connections
Starter motor fuse blown off
Loose starter motor connections
2.
Engine cranks but
Air in the fuel system
Prime the fuel system using priming pump
does not fire
MIL glowing
Check and rectify the fault code
Incorrect Immobilizer pairing
Do immobilzer pairing
Unlearnt vehicle Key
Do immobilizer learning
Damaged vehicle Key
Use new key
Loose cam sensor connections
Rectify the connections
Loose crank sensor connections
Rectify the connections
Loose rail pressure connector
Rectify the connections
Loose EMS ECU connector
Rectify the connections
3.
Engine Overheat
Coolant level low
Top up the coolant
Coolant leakage from radiator cap
Retighten radiator cap
Coolant leakage from the circuit
Rectify the leakage
Coolant hose punctured
Replace the hose
Radiator fans not working
Check the fan connector, loose or
disconnected