TATA Motors 2013 SAFARI STORME Owner's Manual & Service Book - page 123
IN CASE OF EMERGENCY
113
PRELIMINARY TROUBLE SHOOTING
SR. NO. PROBLEM OBSERVED
CAUSE
ACTION TO BE TAKEN
8.
Radiator fans running
Defective refrigerant pressure switch
Rectify the refrigerant pressure switch
continuously even with
MIL ON
Check for the fault code and get it rectified
AC in OFF condition
Defective coolant temperature sensor
Rectify coolant temperature sensor
Engine running hotter than normal
Refer point no. 3
Faulty fan relay
Get the relay rectified
Faulty EMS ECU
Get defect rectified
9.
Accessory belt noise
Low belt tensions
Re-tension the belts
10.
Water in fuel lamp ‘ON’
Water accumulated in water sedmenter
Drain water from fuel pre-filter cum sedimenter
CLUTCH
1.
Clutch does not get
Less clutch pedal height
Set clutch pedal height inline with brake pedal
disengaged
Air in the hydraulic system
Bleed the system
Less fluid in the master cylinder
Get clutch fluid filled
2.
Clutch pedal goes too low
Less clutch pedal height
Set clutch pedal height inline with brake pedal
Air in the hydraulic system
Bleed the system
Less fluid in the master cylinder
Get clutch fluid filled
3.
Clutch pedal return
Less clutch pedal height
Set clutch pedal height inline with brake pedal
sluggish
Blocking of vent in brake fluid
Open the cap from the bottle and clean bottle the
breather hole, if clogged
GEAR BOX
1.
Gears slipping out
Worn/damaged grooves on shifter shaft
Replace
of mesh
Worn shift fork or synchroniser sleeve
Replace
Weak or damaged detent springs
Replace
Worn bearings on input shaft or
layshaft
Replace
Worn dog teeth on sleeve and gear
Replace sleeve and gear