TATA Motors 2013 SAFARI STORME Owner's Manual & Service Book - page 125
IN CASE OF EMERGENCY
115
SR. NO. PROBLEM OBSERVED
CAUSE
ACTION TO BE TAKEN
PRELIMINARY TROUBLE SHOOTING
3.
Brake pulling to one
Oil on the lining/pad
Clean the pad lining
side
One side shoe (pad) worn
Get the shoe pad replaced
Wheel adjustment disturbed
Adjust
Unequal tyre pressure
Adjust
One side brake pipe clogged
Get the brake line cleaned and bleed the system
4.
Brake grab
Improperly adjusted parking brake
Get correctly adjusted
Brake fluid container breather hole
Clean the hole on the container
clogged
No brake pedal free play/brake
Adjust brake pedal Check clevis pin
pedal not returning fully
Defective tandem master cylinder
Replace/rectify tandem master cylinder.
Brake light switch over tightened
Set brake light switch.
5.
Brake Squeal
Defective brake lining/pad
Replace
Glazed lining/pad
Clean or replace lining/pad
Wrong lining/pad
Install correct lining/pad
Front pads /Antisqueal shims
Get corrected
rubbing on the disc
STEERING
1.
Hard steering
For power steering - Less fluid in
Get the recommended fluid topped up
the power steering reservoir.
to correct level
Air in the system
Get the air removed by bleeding the system
Loose pump belt
Get the belt correctly adjusted