DAELIM VJF125 Service Manual - Engine Oil Level Inspection
ENGINE OIL LEVEL INSPECTION
• Erect the motorcycle by main stand.
• Start the engine and let it be warm fully.
• Stop the engine, remove the oil level gauge and wipe it
clean.
• Check the oil level with the level gauge by inserting it
in engine screwing level gauge.
It is good if the oil surface is between the lower level
mark and upper that of the level gauge. If the oil level
is near the lower level mark on the dipstick or below
that, full to the upper level mark with the recommended
oil.
ENGINE OIL CHANGE
• Loosen the drain plug bolt on the LH. crank case and
drain the oil.
• Loosen the oil drain cap on the RH. crank case.
• Clean filter screen with a clean wash. Check if the oil
filter screen seal rubber and O-ring of the tappet adjust
hole are in good condition.
• Unscrew the spark plug from the spark plug cap and
operate the starter motor for a second to remove the
remaining oil from the engine.
• Install the filter screen, spring and tappet adjust hole cap.
TORQUE : 1.5 kgf
·
m
• Fill the crankcase with recommened engine oil.
OIL CAPACITY: 1.5
ℓ
(After disassembly)
1.35
ℓ
(After oil filter change)
1.3
ℓ
(After oil change)
RECOMMENDED ENGINE OIL :
Genuine oil
API classification : SL grade
viscosity : 10W-40
• Install the oil level gauge.
• Start the engine and let it idle for a few minutes.
• Stop the engine and recheck the oil level,if necessary,
supply the recommended oil.
• Check to see if the oil is leak.
3-3
LUBRICATION
•Make the engine warm and erect the motorcycle
with side stand in order to assure complete and rapid
draining.
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL LEVEL GAUGE
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL FILTER SCREEN
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
OIL DRAIN CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
TAPPET ADJUST HOLE CAP
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT
DRAIN PLUG BOLT