Taylor 8657 Operating Instructions Manual - page 50
46
Important: Operator Checklist
Model 8657
081216
between the fins.
Note: For machines equipped with an air filter,
it will be necessary to vacuum clean the filters
on a monthly schedule.
j
8. On water cooled units, check the water lines for
kinks or leaks. Kinks can occur when the
machine is moved back and forth for cleaning or
maintenance
purposes.
Deteriorated
or
cracked water lines should be replaced only by
an authorized Taylor mechanic.
The Air/Mix Pump Checklist:
j
1. Dispose of o--rings and check bands if they are
worn, torn, or fit too loosely, and replace with
new ones.
j
2. Follow lubricating procedures carefully. NEVER
lubricate check bands.
j
3. Never interchange the shake parts with the soft
serve parts.
j
4. Handle plastic pump parts with care to avoid
nicks and cracks.
j
5. Be sure the spring and poppet fit securely over
the mix inlet fitting.
j
6. Clean and sanitize the pressure switch
diaphragm daily.
j
7. Be sure the air/mix pump is properly aligned
with the faceplate of the motor reducer, or
severe and costly damage may occur.
Winter Storage
If the place of business is to be closed during the winter
months, it is important to protect the freezer by
following certain precautions, particularly if the
building is subject to freezing conditions.
Disconnect the freezer from the main power source to
prevent possible electrical damage.
On water cooled freezers, disconnect the water
supply. Relieve pressure on the spring in the water
valve. Use air pressure on the outlet side to blow out
any water remaining in the condenser. This is
extremely important. Failure to follow this procedure
may cause severe and costly damage to the
refrigeration system.
Your local Taylor Distributor can perform this service
for you.
Wrap detachable parts of the freezer such as beater,
blades, drive shaft, and freezer door. Place these parts
in a protected, dry place. Rubber trim parts and
gaskets can be protected by wrapping them with
moisture--proof paper. All parts should be thoroughly
cleaned of dried mix or lubrication which attract mice
and other vermin.