Jeep 1996 Grand Cherokee Service Manual - page 1350
POWER SUNROOF
INDEX
page
page
GENERAL INFORMATION
GENERAL INFORMATION . . . . . . . . . . . . . . . . . . 7
REMOVAL AND INSTALLATION
DRAIN CHANNEL . . . . . . . . . . . . . . . . . . . . . . . . . 9
DRIVE CABLE LOCATORS . . . . . . . . . . . . . . . . . . 9
DRIVE CABLES . . . . . . . . . . . . . . . . . . . . . . . . . . 9
GLASS PANEL . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
GUIDE ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . 10
MOTOR AND DRIVE GEARS . . . . . . . . . . . . . . . . 9
SUNROOF ADJUSTMENT BRACKET . . . . . . . . . . 7
SUNSHADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
WIND DEFLECTOR . . . . . . . . . . . . . . . . . . . . . . . 7
CLEANING AND INSPECTION
GENERAL INFORMATION . . . . . . . . . . . . . . . . . 10
ADJUSTMENTS
GLASS PANEL VERTICAL HEIGHT
ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . 11
GENERAL INFORMATION
GENERAL INFORMATION
All sunroofs are equipped with drain tubes (Fig. 1)
and (Fig. 2). The drain tubes must be kept open to
prevent water from entering passenger compartment.
REMOVAL AND INSTALLATION
WIND DEFLECTOR
REMOVAL
(1) Open sun roof glass panel.
(2) Remove screws holding wind deflector to sun
roof unit side rail (Fig. 3).
(3) Separate wind deflector from vehicle.
INSTALLATION
(1) Reverse preceding operation.
GLASS PANEL
REMOVAL
(1) Position glass to vent position.
(2) Remove wind deflector mechanism covers (Fig.
4).
(3) Position sunshade full rearward.
(4) Loosen nuts holding glass panel to side adjust-
ment brackets show in View B (Fig. 4).
(5) Slide glass panel rearward 12mm (0.5in.) and
separate glass from sunroof unit.
INSTALLATION
(1) Position glass panel in opening with logo rear-
ward and slide panel forward 12 mm (0.5in.).
(2) Verify that attaching nuts are below top sur-
face of glass adjustment brackets.
(3) Close sunroof to center glass panel in roof
opening.
(4) Tighten center nuts to hold adjustment.
(5) Open glass to vent position and tighten nuts to
8 N·m (70.8 in. lbs.).
(6) Close glass and check alignment.
(7) Locate glass to vent position.
(8) Install mechanism covers.
SUNROOF ADJUSTMENT BRACKET
REMOVAL
(1) Remove wind deflector, mechanism covers and
glass panel.
(2) Move glass carriage to vent position and
remove rearward adjustment bolt from adjustment
bracket.
Fig. 1 Drain Tubes
ZJ
BODY
23 - 7