Oce VarioPrint 5000 Operating Manual - page 278
7.3.9 Replacing the cleaning corotron cartridge
268
A29246-X17-X-4-7680 / do701.fm
7.3.9 Replacing the cleaning corotron cartridge
900,000 A4 pages can be printed with the cleaning corotron cartridge. After that,
a warning
message appears on the operator panel. If it is not replaced during the warning period of
another 50,000 A4 pages, the printing system stops and an error message is displayed.
The cleaning corotron cartridge must be replaced at that point.
The procedure for replacing the corotron cartridges is the same for the upper and lower
cleaning stations. The following section shows the procedure for the upper cleaning station.
Proceed as follows:
1.
Press the
2.
Select the print unit concerned and "Cleaning corotron" on the operator panel in the
Press the
3.
Select "Start motor for corotron parking".
4.
When the yellow "Corotrons parked" light comes on, open center doors.
Caution
If you pull out the cleaning station too sharply and quickly, you could pull it beyond
its stop point causing it to drop to the floor. There is a danger of injury to you and of
damage to the cleaning station.
Always slide the cleaning station slowly and evenly to its stop point on the guide rail
(reference speed max. 0.5 m/s).
5.
Lift up the handle and pull the cleaning
station slowly and evenly out of the
system.
Caution
Possibility of damage to the sealing blade edge from the vacuum cleaner nozzle.
When vacuuming, do not touch the edge of the sealing blade.