Jeep Cherokee 2000 Service Manual - page 1959
DRAW FUSE, IGNITION-OFF; AUDIO
SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8F-1
DRAW FUSE, IGNITION-OFF; POWER
DISTRIBUTION SYSTEMS . . . . . . . . . . . 8O-2,8O-5
DRB SCAN TOOL
. . . . . . . . . . . . . . . . . . . . . . . 7-9
DRIP RAIL MOLDING
. . . . . . . . . . . . . . . . . 23-49
DRIVE AXLE ASSEMBLY
. . . . . . . . . . . . . . . . 3-22
DRIVE BELT DIAGNOSIS, ACCESSORY
. . . . . . 7-9
DRIVE BELTS, ENGINE ACCESSORY
. . . . . . . 7-35
DRIVE GEAR, SPEED SENSOR
ROTOR-SPEEDOMETER . . . . . . . . . . . . . . . 21-254
DRIVE REMOVAL/INSTALLATION,
VISCOUS FAN . . . . . . . . . . . . . . . . . . . . . . . . 7-39
DRIVE, VISCOUS FAN
. . . . . . . . . . . . . . . 7-19,7-7
DRIVELINE ANGLE MEASUREMENT
PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
DRIVELINE SNAP
. . . . . . . . . . . . 3-109,3-21,3-70
DRIVER DOOR JAMB SWITCH
. . . . . . . . . . . 8U-2
DRIVER SEAT BELT SWITCH
. . . . . . . . . . . . 8U-2
DRIVER SIDE AIRBAG MODULE
. . . . . 8M-2,8M-6
DRIVER SIDE AIRBAG MODULE TRIM
COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8M-7
DRUM, BRAKE . . . . . . . . . . . . . . . . . . . . . . . . 5-11
DRUM BRAKE, REAR
. . . . . . . . . . . 5-29,5-30,5-5
DRUM BRAKE SHOES
. . . . . . . . . . . . . . . . . . 5-21
DRUM MACHINING, BRAKE
. . . . . . . . . . . . . 5-14
DRUM, OVERRUNNING CLUTCH/LOW-
REVERSE . . . . . . . . . . . . . . . . . . . . . . . . . . 21-175
DRUM/OVERDRIVE PISTON RETAINER,
OVERRUNNING CLUTCH/LOW-
REVERSE . . . . . . . . . . . . . . . . . . . . . . . . . . 21-195
DUAL FUNCTION HIGH PRESSURE
SWITCH (4.0 L) . . . . . . . . . . . . . . . . . . . . . . . 24-4
DUAL FUNCTION HIGH PRESSURE
SWITCH/HIGH PRESSURE CUT-OFF
SWITCH . . . . . . . . . . . . . . . . . . . . . . . 24-16,24-33
DUCTS AND OUTLETS . . . . . . . . . . . . . . . . . 24-33
DUTY CYCLE EVAP CANISTER PURGE
SOLENOID . . . . . . . . . . . . . . . . . . . . . 25-24,25-27
EFFECTS OF INCORRECT FLUID LEVEL
. . 21-126,
21-239
ELECTRIC COOLING FAN . . . . . . . . . . . . . 7-19,7-8
ELECTRIC COOLING FAN—2.5L
. . . . . . . . . . 7-33
ELECTRIC COOLING FAN—4.0L
. . . . . . . . . . 7-34
ELECTRONIC VOLTAGE REGULATOR . . . . . . . 8C-2
ELECTROSTATIC DISCHARGE (ESD)
SENSITIVE DEVICES . . . . . . . . . . . . . . . . . . . 8W-8
ELEMENT AND SENSOR, HEATED SEAT
. . 8N-11,
8N-9
ELEMENT (FILTER), AIR CLEANER
. . . . . . . 14-49
EMERGENCY TOW HOOKS
. . . . . . . . . . . . . . 0-11
EMISSION CONTROL INFORMATION
(VECI) LABEL, VEHICLE . . . . . . . . . . . . . . . . 25-26
EMISSION CONTROLS, EVAPORATIVE
. . . . 25-23
EMISSION SYSTEM
. . . . . . . . . . . . . . . . . . . . 25-1
END CAP, FRONT BUMPER
. . . . . . . . . . . . . . 13-2
END CAP, INSTRUMENT PANEL
. . . . . . . . . 8E-25
END CAP, REAR BUMPER
. . . . . . . . . . . . . . . 13-4
END PLUG, HOUSING
. . . . . . . . . . . . . . . . . 19-12
ENGAGEMENT, IMPROPER CLUTCH
RELEASE OR . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6
ENGINE
. . . . . . . . . . . . . . . . . . . . . . 9-2,9-31,9-62
ENGINE, 2.5L . . . . . . . . . . . . . . . . . . . . . . . . . . 9-1
ENGINE, 4.0L . . . . . . . . . . . . . . . . . . . . 9-119,9-61
ENGINE ACCESSORY DRIVE BELTS
. . . . . . . 7-35
ENGINE ASSEMBLY
. . . . . . . . . . . . . . . . . . . . 9-92
ENGINE ASSEMBLY (SHORT BLOCK),
SERVICE . . . . . . . . . . . . . . . . . . . . . . . . 9-27,9-88
ENGINE, CAMSHAFT POSITION
SENSOR-2.5L . . . . . . . . . . . . . . . . . . . . . . . . 8D-4
ENGINE, CAMSHAFT POSITION
SENSOR—2.5L . . . . . . . . . . . . . . . . . . . . . . 8D-14
ENGINE, CAMSHAFT POSITION
SENSOR—4.0L . . . . . . . . . . . . . . . . . . 8D-15,8D-5
ENGINE COOLANT TEMPERATURE
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-49
ENGINE COOLANT TEMPERATURE
SENSOR—PCM INPUT . . . . . . . . . . . . . . . . 14-30
ENGINE CYLINDER HEAD
. . . . . . . . . . . . . . . 9-54
ENGINE CYLINDER HEAD GASKET
FAILURE DIAGNOSIS . . . . . . . . . . . . . . . 9-13,9-73
ENGINE DIAGNOSIS—INTRODUCTION
. . 9-68,9-8
ENGINE, DISTRIBUTOR CAP-2.5L
. . . . . . . . . 8D-6
ENGINE, DISTRIBUTOR ROTOR-2.5L
. . . . . . 8D-6
ENGINE, DISTRIBUTOR-2.5L . . . . . . . . . . . . . 8D-2
ENGINE, DISTRIBUTOR—2.5L
. . . . . . . . . . 8D-17
ENGINE, ENGINE FIRING ORDER—2.5L
4-CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . 8D-23
ENGINE, ENGINE FIRING ORDER—4.0L
6-CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . 8D-23
ENGINE, EXHAUST MANIFOLD—4.0L
. . . . . . 9-96
ENGINE FIRING ORDER—2.5L
4-CYLINDER ENGINE . . . . . . . . . . . . . . . . . 8D-23
ENGINE FIRING ORDER—4.0L
6-CYLINDER ENGINE . . . . . . . . . . . . . . . . . 8D-23
ENGINE, FUEL INJECTOR RAIL/FUEL
DAMPER—2.5L . . . . . . . . . . . . . . . . . . 14-16,14-5
ENGINE, FUEL INJECTOR RAIL/FUEL
DAMPER—4.0L . . . . . . . . . . . . . . . . . . . . . . 14-17
ENGINE, FUEL RAIL/FUEL DAMPER—
4.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-5
ENGINE, IGNITION COIL RESISTANCE—
2.5L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8D-23
ENGINE, IGNITION COIL RESISTANCE—
4.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8D-23
ENGINE, IGNITION COIL-2.5L
. . . . . . . . . . . . 8D-3
ENGINE, IGNITION COIL—2.5L
. . . . . . . . . . 8D-12
ENGINE, IGNITION COIL—4.0L
. . . . . 8D-12,8D-3
ENGINE MOUNT—REAR
. . . . . . . . . . . . 9-30,9-91
ENGINE MOUNTS—FRONT
. . . . . . . . . . 9-29,9-90
ENGINE OIL LEAK INSPECTION
. . . . . . 9-14,9-74
ENGINE OIL PRESSURE
. . . . . . . . . . . . 9-15,9-75
ENGINE OIL SERVICE
. . . . . . . . . . . . . . 9-27,9-88
ENGINE PERFORMANCE
. . . . . . . . . . . . 9-26,9-87
ENGINE, POWER STEERING PRESSURE
SWITCH—2.5L . . . . . . . . . . . . . . . . . . . . . . 14-47
ENGINE, SPARK PLUG CABLES-2.5L
. . . . . . 8D-2
ENGINE SPECIAL TOOLS, 2.5L . . . . . . . . . . . . . 9-60
ENGINE SPECIFICATIONS
. . . . . . . . . . . . . . . 9-55
ENGINE, STARTER MOTOR NOISE - 2.5L
. . . 8B-8
ENTRY RECEIVER PROGRAMMING,
REMOTE KEYLESS . . . . . . . . . . . . . . . . . . . . 8P-6
ENTRY RECEIVER, REMOTE KEYLESS . 8P-2,8P-5,
8P-8
ENTRY SYSTEM, POWER LOCK SYSTEM
AND REMOTE KEYLESS . . . . . . . . . . . . . . . . 8P-3
ENTRY SYSTEM, REMOTE KEYLESS
. . . . . . 8P-1
ENTRY TRANSMITTER BATTERY
REPLACEMENT, REMOTE KEYLESS . . . . . . . 8P-6
ENTRY TRANSMITTER PROGRAMMING,
REMOTE KEYLESS . . . . . . . . . . . . . . . . . . . . 8P-6
ENTRY TRANSMITTER, REMOTE
KEYLESS . . . . . . . . . . . . . . . . . . . . . . . . 8P-2,8P-5
EQUIPMENT, REFRIGERANT SYSTEM
SERVICE . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-22
EVACUATE, REFRIGERANT SYSTEM
. . . . . . 24-22
EVAP CANISTER
. . . . . . . . . . . . . . . . 25-24,25-27
EVAP CANISTER PURGE SOLENOID,
DUTY CYCLE . . . . . . . . . . . . . . . . . . . 25-24,25-27
EVAPORATION CONTROL SYSTEM
. . . . . . . 25-23
EVAPORATIVE EMISSION CONTROLS
. . . . . 25-23
EVAPORATOR COIL
. . . . . . . . . . . . . . . 24-35,24-4
EXHAUST GRILLE, AIR
. . . . . . . . . . . . . . . . 23-50
EXHAUST MANIFOLD
. . . . . . . . . . . 9-35,9-68,9-8
EXHAUST MANIFOLD, INTAKE . . . . . . . . . . . . 9-95
EXHAUST MANIFOLD—4.0L ENGINE
. . . . . . 9-96
EXHAUST PIPE
. . . . . . . . . . . . . . . . . . . . . . . 11-5
EXHAUST SYSTEM
. . . . . . . . . . . . . . . . 11-1,11-4
EXTENDED IDLE SWITCH—PCM INPUT
. . . 14-30
EXTENSION HOUSING AND PARK LOCK
. . 21-191
EXTENSION HOUSING BUSHING
. . . . . . . . 21-147
EXTENSION HOUSING SEAL
. . . . . . . . . . . . . 21-7
EXTENSION, QUARTER PANEL TRIM
. . . . . 23-54
EXTERIOR LAMPS
. . . . . . . . . . . . . . . . . . . . 8L-20
EXTERIOR MOLDING, FRONT DOOR
GLASS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-39
EXTERIOR MOLDING, REAR DOOR
GLASS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-46
EXTERIOR NAMEPLATES
. . . . . . . . . . . . . . . 23-30
FAILURE DIAGNOSIS, ENGINE CYLINDER
HEAD GASKET . . . . . . . . . . . . . . . . . . . . 9-13,9-73
FAN BLADE
. . . . . . . . . . . . . . . . . . . . . . . . . . 7-39
FAN DRIVE REMOVAL/INSTALLATION,
VISCOUS . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-39
FAN DRIVE, VISCOUS
. . . . . . . . . . . . . . . 7-19,7-7
FAN, ELECTRIC COOLING
. . . . . . . . . . . . 7-19,7-8
FAN RELAY—PCM OUTPUT, RADIATOR
. . . 14-36
FAN—2.5L, ELECTRIC COOLING
. . . . . . . . . . 7-33
FAN—4.0L, ELECTRIC COOLING
. . . . . . . . . . 7-34
FANS, COOLING SYSTEM
. . . . . . . . . . . . 7-3,7-38
FASTENER IDENTIFICATION
. . . . . . . . . . . Intro.-3
FASTENER USAGE . . . . . . . . . . . . . . . . . . . Intro.-3
FBI AXLE, 181
. . . . . . . . . . . . . . . . . . . . 3-16,3-61
FBI AXLE, 181 AND 186
. . . . . . . . . . . . . . . . 3-61
FBI AXLE, 186
. . . . . . . . . . . . . . . . . . . . 3-17,3-61
FBI AXLE, TUBE, 181, AND 186
. . . . . . . . . . 3-16
FBI DIFFERENTIAL BEARING PRELOAD
AND GEAR BACKLASH, 181 . . . . . . . . . . . . . 3-52
FBI DIFFERENTIAL BEARING PRELOAD
AND GEAR BACKLASH, 186 . . . . . . . . . . . . . 3-56
FBI PINION, 181
. . . . . . . . . . . . . . . . . . . . . . 3-36
FBI PINION, 186
. . . . . . . . . . . . . . . . . . . . . . 3-41
FBI PINION GEAR DEPTH, 181
. . . . . . . . . . . 3-48
FBI PINION GEAR DEPTH, 186
. . . . . . . . . . . 3-50
FBI PINION SHAFT SEAL, 181
. . . . . . . . . . . . 3-24
FBI PINION SHAFT SEAL, 186
. . . . . . . . . . . . 3-26
FENDER FLARE, FRONT . . . . . . . . . . . . . . . . 23-31
FENDER FLARE, REAR . . . . . . . . . . . . . . . . . 23-49
FENDER, LEFT FRONT
. . . . . . . . . . . . . . . . . 23-32
FENDER, RIGHT FRONT . . . . . . . . . . . . . . . . 23-32
FILL LEVEL, LUBRICANT
. . . . . . . . 21-347,21-376
FILL PROCEDURE, TRANSMISSION
. . . . . 21-142
FILLER TUBE CAP, FUEL TANK
. . . . . . 14-21,14-6
FILLING, COOLING SYSTEM—DRAINING
. . . 7-21
FILTER, FUEL PUMP INLET
. . . . . . . . . . . . . 14-15
FILTER REPLACEMENT, FLUID
. . . . . . . . . 21-141
FILTER/FUEL PRESSURE REGULATOR,
FUEL . . . . . . . . . . . . . . . . . . . . . . . . . . 14-13,14-3
FINAL ASSEMBLY
. . . . . . . . . . . . . . . . . 3-47,3-85
FINESSE SANDING, BUFFING, AND
POLISHING . . . . . . . . . . . . . . . . . . . . . . . . . . 23-4
FINISH, BASE COAT/CLEAR COAT
. . . . . . . . . 23-4
FIRING ORDER—2.5L 4-CYLINDER
ENGINE, ENGINE. . . . . . . . . . . . . . . . . . . . . . 8D-23
FIRING ORDER—4.0L 6-CYLINDER
ENGINE, ENGINE . . . . . . . . . . . . . . . . . . . . . 8D-23
FITTING CONNECTING ROD BEARINGS
. . . . 9-80
FITTING CRANKSHAFT MAIN BEARINGS
. . . 9-23,
9-83
FITTING, PISTON
. . . . . . . . . . . . . . . . . . . . . . 9-77
FITTINGS, QUICK-CONNECT
. . . . . . . . 14-10,14-6
FIVE VOLT SENSOR SUPPLIES—
PRIMARY AND SECONDARY . . . . . . . . . . . . 14-29
FIXED ORIFICE TUBE
. . . . . . . . . . . . . . 24-35,24-5
FLARE, FRONT FENDER . . . . . . . . . . . . . . . . 23-31
FLARE, REAR FENDER . . . . . . . . . . . . . . . . . 23-49
FLARING, BRAKE TUBE
. . . . . . . . . . . . . . . . . 5-14
FLASHER, COMBINATION
. . . . . . . . . . . 8J-3,8J-5
FLOOR CONSOLE, FULL
. . . . . . . . . . . . . . . 23-57
FLOW AND PRESSURE, POWER
. . . . . . . . . . 19-6
FLOW CHECK PROCEDURE, THROTTLE
BODY MINIMUM AIR . . . . . . . . . . . . . . . . . . 14-42
FLOW CHECK, RADIATOR COOLANT
. . . . . . . 7-17
FLOW TESTING TRANSMISSION MAIN
COOLER . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-246
FLUID
. . . . . . . . . . . . . . . . . . . . . . . 21-220,21-96
FLUID AND FILTER REPLACEMENT
. . . . . . 21-141
FLUID, BRAKE
. . . . . . . . . . . . . . . . . . . . . . . . 5-31
FLUID CAPACITIES
. . . . . . . . . . . . . . . . . . . . . 0-3
FLUID, CAUSES OF BURNT
. . . . . . 21-126,21-240
FLUID, CLUTCH LINKAGE
. . . . . . . . . . . . . . . . 6-9
FLUID CONDITION, CHECKING
. . . . . . . . . 21-248
FLUID CONTAMINATION
. . . . . . . . 21-127,21-240
FLUID CONTAMINATION, BRAKE
. . . . . . . . . . 5-12
FLUID LEAK DIAGNOSIS, CONVERTER
HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . 21-132
FLUID LEVEL, BRAKE
. . . . . . . . . . . . . . . . . . 5-12
FLUID LEVEL CHECK
. . . . . . . . . . . . . . . . . 21-141
FLUID LEVEL, CHECKING
. . . . . . . . . . . . . 21-247
FLUID LEVEL, CLUTCH
. . . . . . . . . . . . . . . . . 6-10
FLUID LEVEL, EFFECTS OF INCORRECT
. . 21-126,
21-239
FLUID LEVEL SENSOR, WASHER
. . . . . . . . . 8K-4
FLUID/FILTER CHANGE, REFILLING
AFTER OVERHAUL OR . . . . . . . . . . . . . . . . 21-248
FLUSH MEASUREMENTS, BODY GAP
. . . . 23-127
FLUSHING COOLERS AND TUBES
. 21-143,21-248
FLUSHING, COOLING SYSTEM—
REVERSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-22
FLYWHEEL
. . . . . . . . . . . . . . . . . . . . . . . . 6-10,6-2
FLYWHEEL RUNOUT, CLUTCH
. . . . . . . . . . . . . 6-6
FOG LAMP
. . . . . . . . . . . . . . . . . . . . . . . . . . 8L-15
FOG LAMP ADJUSTMENT
. . . . . . . . . . . . . . . 8L-8
FOG LAMP BULB
. . . . . . . . . . . . . . . . . . . . . 8L-10
FORM-IN-PLACE GASKETS
. . . . . . . . . . 9-25,9-86
FORWARD CLUTCH
. . . . . . . . . . . . . . . . . . 21-317
FOUR-WHEEL-DRIVE VEHICLE TOWING
. . . . 0-10
FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-6
FRAME AND BUMPERS
. . . . . . . . . . . . . . . . . 13-1
FRAME DIMENSIONS
. . . . . . . . . . . . . . . . . . 13-7
FRAME TORQUE SPECIFICATIONS
. . . . . . . . 13-9
FREQUENCY INTERFERENCE, RADIO
. . . . . . 8F-6
FRONT AXLE BUSHING
. . . . . . . . . . . . . . . . . 2-11
FRONT AXLE PINION INPUT ANGLE
. . . . . . . 3-15
XJ
INDEX
5
Description
Group-Page
Description
Group-Page
Description
Group-Page